Table of Contents
Advertisement
Check that the throttle cables are undamaged, routed without sharp bends, and set
correctly.
Clean the air filter and air filter box.
Change the glass fiber yarn filling of the main silencer.
Service the fork.
(ral
p. 20)
Service the shock absorber.
Check the screws and nuts for tightness.
Change the fuel screen.
(ral
Check the fuel pressure.
(ral
Check the idle speed.
Final check: Check the vehicle for safe operation and take a test ride.
Read out the fault memory after the test ride using the Husqvarna Motorcycles diag-
nostics tool.
Make the service entry in
Husqvarna Motorcycles Dealer.net
Manufacturer Warranty Booklet.
o
One-time interval
•
Periodic interval
28.3
Recommended work
Change the front brake fluid.
Change the rear brake fluid.
Change the hydraulic clutch fluid.
Lubricate the steering head bearing.
Service the fork.
(0
p. 20)
Service the shock absorber.
Change the fuel filter.
(ral
p. 109)
Perform minor engine service, engine has been installed. (Change spark plug and
spark plug connector. Change piston, check and measure cylinder; check cylinder
head. Check the camshaft, rocker arm and rocker arm shafts. Check timing assembly.)
Perform major engine service including removing and installing engine. (Change
valves, valve springs, valve spring seats, and valve spring retainers. Change the
connecting rod, conrod bearing and crank pin. Check the transmission and shift
mechanism. Check the oil pressure control valve. Change the suction pump. Check
the force pump and lubrication system. Change the timing chain. Change all engine
bearings. Change the shaft seal rings and bearing seals of the main bearing.)
o
One-time interval
•
Periodic interval
Every 10 operating hours/after every race
(0
p. 97)
(0
(0
p. 64)
p. 112)
p. 1 05)
(ral
p. 148)
(ral
p. 155)
(ral
p. 249)
(ral
p. 39)
(0
p. 64)
SERVICE SCHEDULE 28
Every 40 operating hours
Every 30 operating hours
Every 20 operating hours
Once after 1 operating hour
p. 94)
and in the Service &
Every 100 operating hours
Every 50 operating hours
Once after 20 operating hours
Once after 10 operating hours
I
I
I
I
I
•
•
•
•
0
•
•
•
I
I
I
•
I
I
•
•
I I
I
I
I
•
I
I
I
I
I
•
I
I
I
•
•
I
•
•
I
I
0
•
•
•
•
I
I
I
0
•
•
•
•
I
I
I
•
•
•
I
I
•
I
0
•
•
•
•
I
I
I
I
I
I
0
•
•
•
•
0
I
I
I
I
I
•
•
•
•
O
Annually
I
I
•
I
I
I
•
•
•
I
0
I
0
•
I
•
•
I
I
•
293
Advertisement
Table of Contents
