Table of Contents
Advertisement
Operating Instructions
6.4
Machine Break-In
Although there are no operational restrictions on
the wood splitter when used for the first time, it is
recommended that the following items be checked:
Review the engine owner's manual for break-in
recommendations. Place the machine in a Safe
Condition before checking any components. Refer to
Safe Condition on page 10.
After 1 hour of operation
1. Check that the push block or wedge is adequately
lubricated.
2. Check all nuts, bolts and other fasteners. Tighten to
their specified torque level.
3. Check hydraulic system for leaks. Tighten
all leaking fittings and replace any leaking
components.
4. Check machine fluid levels—Fuel, engine oil, and
hydraulic oil reservoir. Top up as required.
5. Check for entangled material. Remove all
entangled material before resuming work.
6. Check tire pressure. Inflate as required.
After 8 hours of operation
7. Repeat the above steps.
6.5
Engine Oil Level Check
Check engine oil level daily.
Check with the machine parked on level ground and
the engine stopped.
IMPORTANT! Running the engine with a low
oil level can cause engine damage that is not
covered by warranty.
1. Remove the oil level dipstick and wipe it clean.
2. Fully insert the oil level dipstick, then remove it
to check the oil level. The proper level is when
the oil is visible at the full (upper) mark on the
dipstick.
3. If the oil level is low, add oil until the level is at the
full mark.
SAE 10W-30 or 5W-30 is recommended for
general use.
4. Reinstall the oil level dipstick.
Fig. 12 – Engine Oil Level check
1. Oil Level Dipstick
2. Oil Filler
3. Low Level
4. Full Level
Refer to the engine owner's manual included in the
manual tube for further information on engine oils.
6.6
Hydraulic Oil Level Check
Check hydraulic oil level every 50 hours or weekly.
Check with the machine parked on level ground and
the engine stopped.
The proper level is when the oil is visible at the full
(upper) mark on the dipstick.
24
WXR720/L, WXR740/L
Trailer Wood Splitter
1
2
00616
Advertisement
Table of Contents
