Table of Contents
Advertisement
WXR720/L, WXR740/L
Trailer Wood Splitter
8. Inspect and tighten all bolts, nuts and screws.
Check that all electrical and fuel connections are
properly secured.
9. When completing a maintenance or service
function, make sure all safety shields and devices
are installed before placing splitter in service.
10. When cleaning any parts, do not use gasoline. Use
a cleanser designed for that purpose.
11. Always use proper tools in good condition. Make
sure you understand how to use them, before
performing any service work.
8.2
Fluids and Lubricants
1. Engine Oil
SAE 10W-30 or 5W-30 motor oil is recommended
for general use. Refer to the engine manufacturer's
manual for maintenance and service information
2. Grease
Use an SAE multi-purpose high temperature
grease with extreme pressure (EP) performance.
Also acceptable is an SAE multipurpose lithium-
based grease.
3. Engine Fuel
This engine is certified to operate on unleaded
gasoline with a pump octane rating of 86 or higher
(a research octane rating of 91 or higher).
4. Hydraulic Oil
Use Dexron® III Automatic Transmission Fluid
(ATF). Dexron VI or Mercon® ATF are also
acceptable substitutions.
5. Storing Lubricants
Your machine can operate at top efficiency
only if clean lubricants are used. Use clean
containers to handle all lubricants. Store them in
an area protected from dust, moisture and other
contaminants.
8.3
Maintenance Schedule
Perform maintenance procedures at time shown or
hour interval, whichever comes first.
As Required
Check the condition of all hydraulic lines, hoses and
fittings. Replace any that are damaged.
Remove any entangled material from splitter.
Check that all fasteners are tight.
Every 8 hours or Daily
Check fuel level
Check engine oil level.
Every 50 hours or Annually
Check hydraulic oil level.
Clean engine air filter
Inspect hydraulic oil quality
Grease frame slide, hinges,
pivot points
Every 100 hours or Annually
Grease axle bearings
Change engine oil
Check tire pressure
Change hydraulic oil and filter
Change engine air filter
Clean machine. Remove
debris and entangled
material.
Change fuel filter
33
Service and Maintenance
See page 25
See page 24
See page 24
See page 26
See page 24
See page 34
See page 34
See engine manual
See rating on tire
sidewall
See page 35
See page 26
—
See engine manual
Advertisement
Table of Contents
