Club Car Cafe Express Maintenance And Service Manual page 132

11
Test Procedures
TEST PROCEDURE 3 – Ground Cables
See General Warnings on page 1-1.
NOTE: This is a continuity test for the main ground wire(s) of the vehicle. An additional ground wire is located
on top of the fuel tank.
1. If necessary, see Testing Basics on page 11-14.
2. Disconnect battery and spark plug wire(s). See Disconnecting the Battery-Gasoline Vehicles on page 1-3.
3. Check the following wires and cables for clean, tight connections and continuity (Figure 11-7, Page 11-20):
– Check the starter/generator ground cable (black wire) from A1 terminal to chassis.
– Check the battery ground cable from the disconnected terminal to chassis.
– Check the engine ground cable from engine block to chassis.
4. The reading should be continuity. If the reading is incorrect, clean and tighten cable connections. If the
connections are good and the reading is incorrect, repair or replace the wire or cable.
1. Battery Ground 2. Main Wire Harness Ground 3. Engine Ground Cable 4. Starter/Generator Ground (from A1 Terminal) 5. Voltage Regulator
Ground Wire (from electrical component box)
3023
Page 11-20 2018 Café Express Maintenance and Service Manual
Figure 11-7 Ground Wires and Cables
TROUBLESHOOTING AND ELECTRICAL
SYSTEM: PEDAL-START GAS VEHICLE
2
3
1