Inspection; Periodic Checks; Service; Electric Motor - HADEF 19/90 Installation, Operating And Maintenance Instructions

13

Inspection

Pos : 17.2 /1_H ADEF /13-PRÜFUN G/Wi eder kehrende Pr üfung/01.Wieder kehrende Prüfung @ 0\mod_1175675257580_52.doc x @ 3164 @ @ 1
13.1

Periodic checks

Independently from the regulations of the individual countries, lifting devices must be checked at least yearly
by a qualified person or licensed qualified person regarding its functional safety.
Pos : 17.3 /1_H ADEF /13-PRÜFUN G/NUR Fahr wer ke/T abell e-Inspekti onsinter valle/02.NUR F ahrwer ke @ 1\mod_1185785740034_52.doc x @ 7491 @ @ 1
check screw connections
check the bearings
check the trolley wheels
check lubrication of the driving pinion
buffers - check correct position and wear
electric motor* - check the brake lining
electric motor* - check the brake
pneumatic motor*
Have the equipment checked by an expert
(periodic inspection)
*as far as applicable
Pos : 18.1 /1_H ADEF /14- WARTUN G/*Ü 1* /#. Kapitel - Wartung @ 0\mod_1172647693186_52.doc x @ 409 @ @ 1
14

Service

Pos : 18.2.1 /1_H ADEF /14- WARTUN G/E-Motor/Alle @ 0\mod_1173363774255_52.doc x @ 591 @ @ 1
14.1

Electric motor

For the motor it is sufficient to keep the cooling airways clean and monitor the roller bearing and its
lubrication status.
A high temperature fat must be used if the roller bearing is replaced.
Pos : 18.2.2 /1_H ADEF /---ALLGEMEIN/Hinweis e/VOR SICHT - Br emse: fr ei von Fett, Sc hmutz... @ 0\mod_1177594011189_52.doc x @ 5565 @ @ 1
CAUTION!
Brake linings and surfaces must always be clean and fat-free. Even very small amounts of dirt can reduce
the braking moment considerably.
Pos : 19.1 /1_H ADEF /15-ST ÖRUNG/*Ü 1*/#. Kapitel - Störung @ 0\mod_1172648295608_52.doc x @ 413 @ @ 1
15

Trouble

Pos : 19.2.1 /1_H ADEF /15-ST ÖRUNG/Allgemein/01.Störung @ 0\mod_1173250229044_52.doc x @ 460 @ @ 1
Please pay attention to the following in case of problems:
 Troubles with the equipment must only be repaired by qualified personnel.
 Secure the unit against unintended operation start.
 Put up a warning note indicating that the unit is not to be used.
 Secure the working area of moving parts of the unit.
 Please read the chapter "Safety instructions".
Notes on the repair of faults are found in the following table.
For the repair of failures please contact our service department.
Pos : 19.2.2 /1_H ADEF /---ALLGEMEIN/Hinweis e/VOR SICHT - Störung beseitigen bei Versc hleißteilen @ 0\mod_1177594576085_52.doc x @ 5572 @ @ 1
CAUTION!
Trouble caused by wear or damage to parts such as wire ropes, chains, chain wheels, axes, bearings,
brake parts, etc., must be remedied by replacing the parts with original spare parts.
Pos : 20.1 /1_H ADEF /16-ABHILFE/*Ü 1*/#. Kapitel - Abhilfe @ 0\mod_1176707716661_52.doc x @ 4300 @ @ 1
14
at daily
commissioning checks
X
X
X
X X
X
1st maintenance Inspection
after Maintenance
3 months every
3 months
X X
Inspection
Maintenance
every
12 months
X
X
X
X
X
X
X
5.52.653.00.01.05