Using Your Folder; Power Up; Loading Paper - Martin Yale 2051 Installation Operation & Maintenance

Martin Yale 2051 Folder
®

2 Using Your Folder

After performing all of the steps in section 1 (Folder Setup), you're ready to turn on the folder.
2.1

Power Up

Turn on the power (the power switch is located under the Second
Fold Table). The 2051 Folder will go through a boot up sequence
and the display will show the following messages (see Figure 6,
Figure 7 and Figure 8).
The display in Figure 7 shows the software revision level.
In the event that you must call Martin Yale Support for help,
please have the software revision number available.
When the display shows Figure 8, both fold tables will begin to
move to their respective home positions.
Homing of the fold tables is required to insure a proper and
accurate fold. This operation may take several seconds. Allow
the folder to continue without interruption until the display
indicates that it's ready.
Once the Fold Tables have been homed, the display will toggle
between 2 different messages (Figure 9 and Figure 10).
The "Custom Fold Set" message will be displayed when none
of the "Fold Type" lights are illuminated. This also indicates that
the folder does not recognize the Fold Table positions as a
standard fold type. This is typically referred to a "Manual Mode".
2.2

Loading Paper

To load paper into the Feed Table, firmly push the Feed Table
down as show in Figure 11, until it locks into the "Load" position as shown in
Load the paper into the Feed Table as shown in
folder, and that the leading edge of the stack is resting against the face indicated.
The Feed Table is capable of holding 500 sheets of 20# bond paper, or a stack of paper 2 1/8
inches high, up to the maximum rated weight of paper for this folder.
Revision 3.0
Figure 11
Martin Yale Industries, Wabash, Indiana, USA 260-563-0641
, making sure that the paper is fully within the
Figure 12
(2051.09.03.16.11.40)
Model 2051 By
Martin Yale Ind.
Figure 6
Model 2051
Revision XX.XX
Figure 7
Homing Fold Tables Please
Stand By
Figure 8
No Paper Present
Qty Done =
Figure 9
Custom Fold Set
Qty Done =
Figure 10
.
Figure 12
Figure 12
0
0
Page 9 of 52