Folder Setup; List Of Components; Setting Up Your New Folder; Power Connection - Martin Yale 2051 Installation Operation & Maintenance

Martin Yale 2051 Folder
®

1 Folder Setup

1.1

List of Components

Your shipping container comes complete with the following items;
Qty 1 – 2051 Folder
Qty 2 – Fold Table Assembly
Qty 2 – Feed Table Extension
Qty 1 – Power Cord
Qty 1 – Dejam Handle
Qty 1 – 9/64" Hex Key
The Fold Table Assemblies are shipped in their own box and included within the folder container. The
Feed Table Extensions and the Dejam Handle are in their own box as well.
1.2

Setting Up Your New Folder

Place your folder on a sturdy, flat surface such as a table, desk, or bench. Inspect your folder for signs
of damage. If damage is apparent, call the freight carrier immediately, then call Martin Yale for
instructions.
1.3

Power Connection

The Power Cord for the folder is a standard computer
power cord. Plug the female end of the power cord plug
into the folder's power connection (Figure 1).
The power switch is located on the same surface as the
power connection, nearest the front of the folder.
Insure the proper voltage is connected to the
2051 or damage can occur. The 2051 voltage
requirement can be found on the serial label located
just to the right of the power connection.
1.4

Fold Tables

Both fold tables are the same, and can be installed into
either the first (upper, right) or second (lower, left) fold table
positions. The fold table is locked into position by 4 (four)
pins located in the folder.

1.4.1 First Fold Table Installation

To install the first fold table, refer to Figure 2.
Step 1: slide the front slot opening of the fold table onto the
inner set of pins (closest to the folding rollers).
Step 2: lower the fold table onto the outer set of pins with a
light amount of downward pressure as shown. There will be
a slight snapping action as the fold table drops into the detent
position.
Revision 3.0 Martin Yale Industries, Wabash, Indiana, USA 260-563-0641
(2051.09.03.16.11.40)
Figure 1
Figure 2
Page 7 of 52