Introduction; About This Functional Profile; Profibus Dp-V0; Profibus Dp-V1 - Grundfos CIM 150 PROFIBUS DP Functional Profile And User Manual

2. Introduction

2.1 About this functional profile

This functional profile describes these protocols for the Grundfos
booster systems mentioned below:
• CIM/CIU 150 PROFIBUS DP
• CIM/CIU 500 ethernet for PROFINET IO.
Grundfos booster systems:
• Grundfos Hydro MPC (CU 35X)
• Grundfos Control MPC (CU 35X)
• Grundfos Hydro Multi-E model G
• Grundfos Hydro Multi-E model H and later
• Grundfos TPED model H and later, twin-head pump
• Grundfos MAGNA3-D, twin-head pump.
All Multi-E systems that are based on MGE model G and earlier
models will be referred to as Multi-E model G.
All Multi-E systems that are based on MGE model H and later
models will be referred to as Multi-E model H.
The data modules for Hydro MPC and Control MPC are identical,
so in the following, only Hydro MPC is mentioned. If not
specifically mentioned, Hydro Multi-B, Hydro MPC, Hydro Multi-E
model G and Hydro Multi-E model H are referred to as "booster
system".
Grundfos cannot be held responsible for any problems caused
directly or indirectly by using information in this functional profile.

2.2 PROFIBUS DP-V0

The PROFIBUS DP interface conforms to the PROFIBUS DP-V0
standard for cyclic data transmission.
The option of setting the PROFIBUS DP address via bus is not
supported as CIM 150 has two switches for setting the address.

2.3 PROFIBUS DP-V1

Only the diagnostic part and the extra three bytes of
parameterisation data are supported. Acyclic data transmission is
not supported.

2.4 Assumptions

This functional profile assumes that the reader is familiar with
commissioning and programming of PROFIBUS and PROFINET
devices.

2.5 Definitions and abbreviations

Address Resolution Protocol. Translates
ARP
IP addresses into MAC addresses.
Ensures that both crossover cable types
Auto-MDIX and non-crossover cable types can be
used.
Ethernet cable type with four twisted pairs
CAT5
of wires.
Enhanced CAT5 cable with better
CAT5e
performance.
Ethernet cable compatible with CAT5 and
CAT6
CAT5e and with very high performance.
CIM Communication Interface Module.
CIU Communication Interface Unit.
Grundfos pump controller and booster
Control MPC
system.
Cyclic Redundancy Check. A data error
CRC
detection method.
Dynamic Host Configuration Protocol.
DHCP Used to configure network devices so that
they can communicate on an IP network.
Domain Name System. Used to resolve
DNS
host names to IP addresses.
Enumeration List of values.
GENIbus Proprietary Grundfos fieldbus standard.
GENIpro Proprietary Grundfos fieldbus protocol.
Grundfos GO
Remote
H
HTTP
Hydro MPC
Hydro Multi-E
IANA
IP
LED
Local mode
MAC
Ping
Q
Remote mode
SELV
SELV-E
SMA
SMTP
SNTP
TCP
TCP/IP
Transmission speed Bits transferred per second, bits/s.
URL
UTC
UTF-8
Pumpland.ru
A Grundfos application designed to
control Grundfos products via infrared or
radio communication. Available for iOS
and Android devices.
Head (pressure).
Hyper Text Transfer Protocol. The
protocol commonly used to navigate the
world wide web.
Grundfos booster system.
Grundfos booster system.
Internet Assigned Numbers Authority.
Internet Protocol.
Light-Emitting Diode.
The booster system uses the setpoint and
operating mode set on CU 35X (MPC) or
with Grundfos GO Remote (Hydro Multi-
E).
Media Access Control. Unique network
address for a piece of hardware.
Packet InterNet Groper. A software utility
that tests connectivity between two TCP/
IP hosts.
Flow rate.
The booster system uses the setpoint and
operating mode set from the bus.
Separated or Safety Extra-Low Voltage.
Separated or Safety Extra-Low Voltage
with earth connection.
SubMiniature version A. Coaxial radio
signal cable connection standard.
Simple Mail Transfer Protocol.
Simple Network Time Protocol. Used for
clocks synchronisation between computer
systems.
Transmission Control Protocol. Protocol
suitable for Internet communication and
Industrial Ethernet communication.
Transmission Control Protocol/Internet
Protocol. Protocol for Internet
communication.
Uniform Resource Locator. The address
used to connect to a server.
Coordinated Universal Time. The primary
time standard by which the world
regulates clocks and time.
Unicode Transformation Format.
Character encoding.
3