Suzuki VZR1800 2007 Service Manual page 443

10-10 ELECTRICAL SYSTEM
REGULATED VOLTAGE
• Remove the front seat. (!9-4)
• Start the engine and keep it running at 5 000 r/min with the
dimmer switch turned HI position.
• Measure the DC voltage between the + and - battery termi-
nals using the multi-circuit tester. If the voltage is not within
the specified value, inspect the generator and regulator/recti-
fier. (!10-10 and -11)
NOTE:
When making this test, be sure that the battery is in fully-charged
condition.
" 09900-25008: Multi-circuit tester set
' Tester knob indication: Voltage (&)
$ Regulated voltage (Charging output):
GENERATOR COIL RESISTANCE
• Remove the fuel tank. (!6-3)
• Remove the left frame side cover. (!9-5)
• Remove the left frame lower side cover. (!3-6)
• Disconnect the generator coupler 1.
• Measure the resistance between the three lead wires.
If the resistance is out of specified value, replace the stator
with a new one. Also, check that the generator core is insu-
lated properly.
" 09900-25008: Multi-circuit tester set
( Tester knob indication: Resistance (Ω)
$ Generator coil resistance: 0.2 – 1.5 Ω (Black – Black)
NOTE:
When making above test, it is not necessary to remove the gen-
erator.
14.0 – 15.5 V at 5 000 r/min
∞ Ω (Black – Ground)
Battery
DCV
B
B
B