Table Of Contents - Carrier 42QHC007D8S Installation Manual

READ BEFORE INSTALLATION
This product has been det ermined t o be in compliance wit h t he Low Volt age Direct ive
( 2014/35/EU), and t he Elect romagnet ic Compat ibilit y Direct ive ( 2014/30/EU) of t he
European Union.
(Waste Electrical & Electronic Equipment)
(When using air conditioner in European, the following guidance must be followed)
- This marking shown on the product or its literature, indicates that waste electrical and
eletrical equipment (WEEE as in directive 2012/19/EU) should not be mixed with general
household waste.It is prohibited to dispose of this appliance in domestic household waste.
For disposal, there are several possibilities:
1.The municipality has established collection systems, where electronic waste can be
disposed of at least free of charge to the user.
2.When buying a new product, retailer will take back the old product at least free of charge.
3.The manufacturer will take back the old appliance for disposal at least free of charge to the
user.
4. As old products contain valuable resources, they can be sold to scrap metal dealers.
Wild disposal of waste in forests and landscapes endangers your health when hazardous
substances leak into the ground-water and find their way into the food chain.
This product contains fluorinated gases covered by the Kyoto Protocol
Chemical Name of Gas
Global Warming Potential (GWP) of Gas
CAUTION
1. Paste the enclosed refrigerant label adjacent to the
charging and/or recovering location.
2. Clearly write the charged refrigerant quantity on the
refrigerant label using indelible ink.
3. Prevent emission of the contained fluorinated gas.
Ensure that the fluorinated gas is never vented to
the atmosphere during installation, service or disposal.
When any leakage of the contained fluorinated gas is
detected, the leak shall be stopped and repaired as
soon as possible.
01
Indoor Unit Dimension(IDU)
42QHC007D8S
730×192×291
4 2 Q H C 0 0 9 D 8 S
42QHC012D8S 812×192×300
42QHC018D8S 973×218×319
42QHC024D8S 1082×225×338
42QHB09E8S
802×189×297
42QHB12E8S
The manufacturer reserves the right to change any product specifications without notice.
Correct Disposal of This Product
R410A / R32
2088 / 675
4. Only qualified service personnel are allowed to access
and service this product.
5. Any handling of the fluorinated gas in this product,
such as when moving the product or recharging the
gas, shall comply under (EC) Regulation No. 517/2014
on certain fluorinated greenhouse gases and any
relevant local legislation.
6. If the system has a leak-detection system installed, it
must be checked for leaks at least every 12 months
7. When the unit is checked for leaks, proper record-
keeping of all checks is strongly recommended.
Outdoor Unit Dimension(ODU) Rated Voltage & Hz
38QHC009DS 700×275×550
38QHC009ES /38QHC009D8S 770×300×555
38QHC012DS/38QHC012D8S 770×300×555
38QHC012ES 800×333×554
38QHC018DS/38QHC018ES
220-240V~ 50Hz
800×333×554
38QHC018D8S
38QHC024DS/38QHC024ES
845×363×702
38QHC024D8S
38QHB09E8S
800×333×554
38QHB12E8S
CONTENTS
1. PREPARING FOR INSTALLATION ····································································
1.1 Safety Percautions
·······················································································
1.2 Accessories ·······························································································
1.3 Installation Site Choosing ···············································································
2. INDOOR UNIT INSTALLATION ·········································································
2.1 Indoor Unit Mounting Plate ··············································································
2.2 Installation Process
······················································································
3. OUTDOOR UNIT INSTALLATION ····································································
3.1 Outdoor Unit Mounting Dimension ····································································
·································································
3.2 Space Requirement For Outdoor Unit
··············································································
3.3 Outdoor Wire Connection
···············································································
3.4 Install The Outdoor Unit
3.5 Install The Drain Pipe For Outdoor Unit ·······························································
4. REFRIGERANT PIPING WORK ········································································
4.1 Flaring ····································································································
4.2 Piping Work
·······························································································
4.3 Refrigerant Pipe ·························································································
··························································································
4.4 Air Evacuation
····························································································
4.5 Leakage Test
5. WIRING ········································································································
6. FINAL CHECK AND TRAIL OPERATION ··························································
6.1 Final Check List ··························································································
6.2 Manual Operation ························································································
6.3 Trail Operation ····························································································
7. INFORMATION SERVICING ·············································································
Caution: Risk of fire
for R32/R290 refrigerant only
3
3
5
6
7
7
8
9
9
9
10
10
10
11
11
11
12
12
12
13
14
14
14
14
15
02