Tuning The Engine; Checking The Play In The Throttle Cable; Adjusting The Play In The Throttle Cable - Husqvarna TC 65 Owner's Manual

15

TUNING THE ENGINE

15.1

Checking the play in the throttle cable

15.2

Adjusting the play in the throttle cable

–
Check the throttle grip for smooth operation.
–
Move the handlebar to the straight-ahead position. Move the throttle grip back-
wards and forwards to ascertain play
Play in gas throttle cable
» If the throttle cable play does not meet specifications:
–
Adjust the play in the throttle cable.
Danger
400192-11
Danger of poisoning Exhaust gases are toxic and inhaling them may
result in unconsciousness and death.
–
–
–
Start the engine and let it idle. Move the handlebar to and fro over the entire
steering range.
The idle speed should not change.
» If the idle speed changes:
–
Adjust the play in the throttle cable.
Preparatory work
–
Remove the seat. (
–
Remove the right side cover. (
–
Remove the left side cover. (
–
Turn the knurled screw on the fuel tap all the way clockwise.
–
Remove the fuel tank.
–
Check the throttle cable routing. (
Main work
–
Move the handlebar to the straight-ahead position.
–
Push back sleeve
–
Ensure that the throttle cable sleeve is pushed all the way into barrel adjuster
–
Loosen nut
E00538-10
–
Turn barrel adjuster
cable sleeve.
Guideline
Play in gas throttle cable
–
Tighten nut
–
Slide on sleeve
400192-11
Finishing work
–
Install the fuel tank.
–
Install the right side cover. (
–
Install the left side cover. (
–
Mount the seat. (
–
Check the play in the throttle cable. (
Always make sure there is sufficient ventilation when running the
engine.
Use an effective exhaust extraction system when starting or running
the engine in an enclosed space.
p. 44)
p. 39)
p. 41)
( p. 47)
p. 53)

.

.

until throttle cable play
 .

.
( p. 48)
p. 40)
p. 42)
p. 44)

in the throttle cable.
3... 5 mm (0.12... 0.2 in)
( p. 75)
( p. 75)

exists at the bottom throttle
3... 5 mm (0.12... 0.2 in)
p. 75)
75

.