Diamond DA 40 Flight Manual page 133

DA 40 AFM
(c) Engine Will Not Start After Injection ("Flooded Engine")
1. Strobe light (ACL) . . . . . . . . . . . . . . . . . . . . ON
2. Electrical fuel pump . . . . . . . . . . . . . . . . . . . OFF
3. Mixture control lever . . . . . . . . . . . . . . . . . . LEAN, fully aft
4. Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . at mid position
Before starting the engine the pilot must ensure that the
propeller area is free and no persons can be endangered.
Do not overheat the starter motor. Do not operate the starter
motor for more than 10 seconds. After operating the starter
motor, let it cool off for 20 seconds. After 6 attempts to start
the engine, let the starter cool off for half an hour.
5. Ignition switch . . . . . . . . . . . . . . . . . . . . . . . START
6. Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . pull back towards IDLE
CONTINUED
Doc. # 6.01.01-E
WARNING
CAUTION
Rev. 8 01-Dec-2010
Normal Operating
Procedures
when engine fires
Page 4A - 17