Diamond DA 40 Flight Manual page 131

DA 40 AFM
(b) Warm Engine
1. Strobe light (ACL) . . . . . . . . . . . . . . . . . . . . ON
%
2. Electrical fuel pump . . . . . . . . . . . . . . . . . . . ON, note pump noise and
%
3. Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 cm (1.2 in) forward from
4. Mixture control lever . . . . . . . . . . . . . . . . . . RICH for 1 - 3 sec, then
Before starting the engine the pilot must ensure that the
propeller area is free and no persons can be endangered.
Do not overheat the starter motor. Do not operate the starter
motor for more than 10 seconds. After operating the starter
motor, let it cool off for 20 seconds. After 6 attempts to start
the engine, let the starter cool off for half an hour.
5. Ignition switch . . . . . . . . . . . . . . . . . . . . . . . START
CONTINUED
Doc. # 6.01.01-E
WARNING
CAUTION
Rev. 8 01-Dec-2010
Normal Operating
Procedures
fuel pressure increase
IDLE (measured from rear of
slot)
LEAN
Page 4A - 15