Off-Board Battery Charger - Golden Technologies Buzzaround XL GB146 Service Manual

Component: Off-Board Battery Charger
Location: Stored inside a pouch on the seatback.
Function: Recharges batteries.
Connections: Connects to the charger port on the battery pack (14b) or the charger port on the tiller.
Refer to figure 11 on page 10. Charger port (14b) is located on the battery pack or on the tiller.
Connects the charger to the batteries. Tiller port connected to the batteries through the main harness.
Failure Signs: Charger power LED does not go on. Batteries will not charge.
Tests: Charger tests vary. Some chargers may be tested by measuring positive
and negative leads on the charger connector. Other chargers need to see battery voltage before charging.
Expected reading: Varies with charger.
See charger test on page 11.
Test charger harness and fuse for continuity.
Serviceable: Replace if necessary.
NOTE: Some Off-Board Battery Chargers may have a switch that enables them to be used with either 110 VAC or
230 VAC. This switch is typically located on the end of the charger. Some may also have a removable glass fuse.
*Fuses must be replaced with exact type and rating.*
9
Buzzaround XL_SG_REVA_100711