Maintenance; Lubrication; Flue; Service And Parts Information - Vulcan-Hart GH30 Installation & Operation Manual

Gh series heavy duty gas ranges

Hide thumbs Also See for GH30:

Table of Contents

Burned-On Foods and Grease

Soaking with hot soapy water will help greatly to remove burned-on foods and grease. Stubborn

deposits can be removed with scouring powder mixed into a paste and applied with stainless steel wool

or sponges. Do not use ordinary steel wool because particles can become embedded and eventually

rust, causing unsightly spots and stains.

Heat Tint

Straw-colored or slightly darkened areas may appear on stainless steel in and around ovens and

ranges where temperatures reach 500°F (260°C) or more. This "heat tint" is caused by a slight

oxidation of the stainless steel and is not harmful.

To control or minimize this condition, never use more heat than is absolutely necessary.

Heat tint can be removed by scouring vigorously with stainless steel wool and a paste made of scouring

powder. Remember to rub in the direction of the polish lines.

Commercial heat tint remover products may also be used.

Precautions

When scraping off heavy deposits of grease or oil from stainless steel equipment, never use ordinary

steel scrapers and knives. Particles of ordinary steel may become embedded in, or lodge on, the

surface of the stainless steel. These will rust, causing unsightly stains and possible contamination of

food. Where it is necessary to scrape, use stainless steel, wood, plastic or rubber tools.

MAINTENANCE

WARNING: (CONVECTION OVEN MODELS ONLY) DISCONNECT ELECTRICAL POWER SUPPLY

BEFORE PERFORMING ANY MAINTENANCE OPERATIONS.

Motors in Vulcan convection ovens are permanently lubricated and require no additional maintenance.

If the gas valve is hard to turn or leaking, contact your local service agency.

Annually check the flue when it is cool to be sure it is free of obstructions.

To obtain service and parts information concerning this range, contact the Vulcan Service Agency

in your area (refer to listing supplied with the range), or Vulcan-Hart Company Service Department at

the address or phone number shown on the front cover of this manual.

– 30 –

Table of Contents