Frymaster H55 Series Technical Reference Manual page 101

Perform an Auto Filter or OQS Filter (if applicable) on a vat to ensure the filter pump is operational and check the drain and return
system for leaks. If OQS is installed, TPM value/Oil is Good______________
Remove old Fryer's Friend from the store and replace with the new Fryer's Friend
The startup tech is responsible for training the operators following the following the steps below.
™
F Q F T
ILTER UICK RYER
Ensure all trainees refer to the Quick Reference, Quick Start, Controller Manual and Operation
Manual located in the manual holder inside the fryer door for the following.
Hands on demonstration and performance are essential for all trainees.
CREW / FILTRATION PERSON(S) / MANAGERS
OVERVIEW
Provide an overview of what a FilterQuick is vs. traditional fryer – Smaller vat, Low Oil Volume
Explain the benefits when used properly – Use less oil, Semi-automatic Filter, Auto Top Off
CONTROLLER
Identify FilterQuick ™ Controller buttons and functions / LED's for filtration – Refer to the FilterQuick
Quick Start Guide
ON / OFF Buttons — Demonstrate full and split functions.
Cook Cycle Buttons — Demonstrate a cook cycle/stop a cook cycle.
Exit Cool Button — Demonstrate entering and exiting the energy-saving Cool Mode.
Temp Button — Demonstrate Use: ON – Setpoint and vat temperature; OFF – Temp, time, date, software
versions.
Checkmark Button — Demonstrate Use: ON – Enter codes, respond to prompts; OFF – Press and hold 3
seconds: Scroll filter usage.
Filter Button — Demonstrate Use: Press and release: Cooks remaining or percentage and cooks remaining to
filter prompt; Press and hold: Filter options.
Exit Scan — Demonstrate Use: Scan programmed menu items and exit menus.
JIB Reset switch / Bulk fill switch on bulk fresh oil systems
Master Power Switch (per vat) (Electric and US ONLY)
MIB Display Window – "A" for Auto or "P" filter pan installation issue. Check for proper installation of pan.
Reset switch (Behind control box in far right Electric fryers, under control box in far left Gas fryers)
Demonstrate JIB System (JIB and Bulk Oil Systems) – Refer to the FilterQuick
Installation and Operation Manual
Demonstrate setup of the JIB
Filling vats with oil (Bulk or JIB)
AUTO TOP-OFF (ATO) – Refer to the FilterQuick
Manual
Instruct on function Top Off Oil Empty Display.
Demonstrate pressing and holding the JIB reset button after JIB replacement will clear the top off empty
message and reset the top off system
Demonstrate Auto Top-Off on a vat by moving oil out of vat.
FILTRATION – Refer to the FilterQuick
Demonstrate assembly of the filter pan (Emphasize need for daily filter paper/pad change / more often as
needed)
Demonstrate FILTER. Show "FILTER NOW" displayed on vat to be filtered. Explain YES and NO responses.
Air bubbles should only be observed in unit being filtered.
Show filtration issues (OIL TOO LOW – Oil level is too low to filter; Errors created by not changing the
paper/pad (monitor oil returned to vat levels – should be where it started)
Show FILTER BUSY message by trying to filter or perform a filter menu function while another vat is filtering.
Automatic Filtering Fryers
RAINING
™ Quick Start Guide and the Installation and Operation
™ Quick Start Guide and the Installation and Operation Manual
Page 2 of 4
4-57
™
™ Quick Start Guide and the