Suzuki SY413 Service Manual page 4991

WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System:
D Service on and around the air bag system components or wiring must be performed only by
an authorized SUZUKI dealer. Refer to "System Components and Wiring Location View" un-
der "General Description" in air bag system section in order to confirm whether you are per-
forming service on or near the air bag system components or wiring. Please observe all
WARNINGS and "Precautions" in air bag system section before performing service on or
around the air bag system components or wiring. Failure to follow WARNINGS could result
in unintentional activation of the system or could render the system inoperative. Either of
these two conditions may result in severe injury.
D Technical service work must be started at least 90 seconds after the ignition switch is turned
to the "LOCK" position and the negative cable is disconnected from the battery. Otherwise,
the system may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
NOTE:
D For the descriptions (items) not found in this section, refer to the same section of Service Manual men-
tioned in FOREWORD of this manual.
D All brake fasteners are important attaching parts in that they could affect the performance of vital parts
and systems, and/or could result in major repair expense. They must be replaced with one of same part
number or with an equivalent part if replacement becomes necessary. Do not use a replacement part of
lesser quality or substitute design. Torque values must be used as specified during reassembly to as-
sure proper retention of all parts. There is to be no welding as it may result in extensive damage and
weakening of the metal.
ON-VEHICLE SERVICE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Excessive Pedal Travel Check
Fluid Pressure Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
BRAKE BOOSTER REPAIR
Remove and Install Brake Booster
TIGHTENING TORQUE SPECIFICATIONS
SPECIAL TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SECTION 5
BRAKES
CONTENTS
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
BRAKES 5-1
5
5-2
5-2
5-2
5-4
5-4
5-5
5-5