Mitsubishi S12R-T2MPTK Operation & Maintenance Manual page 13

Fig. 8-20 Oil Filter - Replace While Engine is
Running .............................................. 8-15
Fig. 8-21 Governor Oil Filter - Change .............. 8-17
Fig. 8-22 Coolant Expansion Tank Cap............. 8-18
Fig. 8-23 Coolant Drain Cock (Engine Body) .... 8-18
Fig. 8-24 Coolant Drain Cock (Water Pump)..... 8-19
Fig. 8-25 Seawater Drain Cock
(Heat Exchanger) ............................... 8-20
Fig. 8-26 Seawater Pump Cover ....................... 8-20
Fig. 8-27 Seawater Pump Impeller - Inspect ..... 8-21
Fig. 8-28 Seawater Strainer Mesh Filter - Clean
and Replace ....................................... 8-22
Fig. 8-29 Mounting Orientation of Strainer Mesh
Filter ................................................... 8-22
Fig. 8-30 Arrangement to Top Cover................. 8-22
Fig. 8-31 Turbocharger - Inspect ....................... 8-23
Fig. 8-32 Pre-cleaner - Wash ........................... 8-23
Fig. 8-33 Battery Electrolyte Level - Check ....... 8-24
Fig. 8-34 Specific Gravity of Battery Electrolyte -
Check ................................................. 8-25
Fig. 8-35 Starter - Inspect.................................. 8-26
Fig. 8-36 Alternator - Inspect ............................. 8-26
Fig. 10-1 Lifting Hangers ................................... 10-1
Fig. 10-2 Hiching Wire Ropes............................ 10-1
Fig. 13-1 Electrical Wiring Diagram ................... 13-1
Fig. 13-2 Electrical Wiring Diagram ................... 13-2
List of Table
Table 2-1 Instrument Panel .....................................2-7
Table 2-2 About Stop Panel.....................................2-9
Table 4-1 Recommended Fuel ................................4-1
Table 4-2 Recommended limit and use limit of
fuel property.............................................4-2
Table 5-1 Table of Recommended Limit of
Engine Oil Properties...............................5-2
Table 5-2 Table of Engine Oil Properties.................5-4
Table 6-1 Water quality standards...........................6-1
Table 6-2 LLC Quality Requirements ......................6-3
Table 6-3 Recommended LLC Concentration .........6-7
Table 7-1 MAINTENANCE SCHEDULE..................7-2
Table 8-1 Specific Gravity of Electrolyte................8-25
Table 9-1 Table of Recommended Rust-Preventive
Oil and Corrosion Inhibitor.......................9-1
Table 11-1 Procedures when abnormal decrease in
engine oil pressure occurs.....................11-2
Table 11-2 The Starter Does not Crank or Cranks
Slowly, Resulting in Start Failure...........11-3
Table 11-3 Starter Cranks, but Engine Does Not
Start .......................................................11-4
Table 11-4 Insufficient Output..................................11-5
Table 11-5 Exhaust Smoke is White or Blue ...........11-6
Table 11-6 Exhaust Smoke is Black or Charcoal ....11-7
Table 11-7 Excessive Fuel Consumption ................11-8
Table 11-8 Excessive Engine Oil Consumption.......11-9
Table 11-9 Overheating ...........................................11-9
Table 11-10Engine Oil Pressure Drop...................11-10
Table 12-1 Main Specifications................................12-1
CONTENTS
CONTENTS-5