12 Troubleshooting; Fault Table - Rechargeable Battery; Fault Table - Wacker Neuson AP 2560e Operator's Manual

12 Troubleshooting,

12 Troubleshooting
DANGER
Danger to life from unauthorized troubleshooting.

12.1

Fault table - rechargeable battery

Pictogram
*
Contact your Wacker Neuson contact partner.
12.2

Fault table

Fault
The machine will not operate.
The machine is displaying
unexpected faults during
commissioning or operation.
30
,
If faults occur with this machine that are not described in this manual, contact the
manufacturer. Do not eliminate the faults independently.
LED over
Pictogram
Fault LED comes

on.
Fault LED stays

on.
Temperature LED
comes on.
Maintenance LED
comes on.
Possible cause
The charge state of the
rechargeable battery is too low.
The rechargeable battery is not
properly installed in the machine.
The rechargeable battery is
defective.
The starter lever is in the forward
position when ON switch on the
rechargeable battery was
actuated.
Refer to the rechargeable battery
faults table.
Possible cause
Voltage too high.

Contacting error.

Hardware error.

Temperature error
(over/under
temperature).
The rechargeable battery
was disabled due to a
fault.
Remedial measure
Isolate the rechargeable battery

from the machine or the charging
unit.
Clean and if necessary dry the

contacts.
Resume operations with the

machine and clear the fault with the
button.
*

Operate the machine only in the

permitted temperature range.
Allow the equipment to cool down if

necessary.
Resume operations with the

machine and clear the fault with the
button.
*
Remedial measure
Charge the rechargeable battery.
Install the rechargeable battery
properly in the machine.
*
Put the starter lever in the OFF
position.
Press the ON/OFF start button and
remove the rechargeable battery if
the fault persists *
100_0202_ts_0017.fm