Thermal Solutions ARCTIC Series Installation & Operation Manual page 4

I. Introduction
Table 1: Water Flow Switch Settings
II. Pre-Installation
Table 2: Clearances and Serviceability
III. Installation
Table 3: Typical Condensate Flow Rate
IV. Venting
Table 4: Vent and Combustion Air Pipe Diameters
and Maximum Lengths
Table 5: Vent and Combustion Air Equivalent Length
Calculation Worksheet
Table 6: Vent Air Pressure Drop Data
Table 7: Combustion Air Pressure Drop Data
Table 8: Combustion Air and Flue Gas Requirements
Table 9: Approved Vent Manufacturers and
Materials
Table 10: Stainless Steel and CPVC Vent Adapters 20
Table 11: Polypropylene Vent Adapters
Table 12: Stainless Steel Vent and Intake
Terminations
Table 13: Polypropylene Vent and Intake
Terminations
Table 14: Recommended Venting Configurations
and Material Options
Table 15: Other than Direct Vent Terminal
Clearances
Table 16: Table of Acceptable Terminations
V. Requirements
Table 17: Electrical Requirements
Table 18: Gas Supply Requirements
Table 19: Sound Pressure Levels
Table 22: Water Flow Rates for Primary/Secondary
Pumping at 20°F ΔT
Table 23: Water Flow Rates for Primary/Secondary
Pumping at 40°F ΔT
Table 20: Minimum Water Flow Rates for Variable
Primary Pumping
Table 21: Maximum Water Flow Rate for Variable
Primary Pumping
Table 24: Water Flow Rates for Constant Volume
Primary Pumping
Table 25: GPM Increase for Glycol System
4
Thermal Solutions, 1175 Manheim Pike, Lancaster, PA 17601 Website: www.thermalsolutions.com
Table of Tables
Phone: 717-239-7642 Fax: 877-501-5212 Email: sales@thermalsolutions.com
5 VI. Before Operation
6 Table 26: Chemical Agents and Effects
8
Table 27: Recommended Feed Water Limits
9 VII. System Start-Up
10 Table 28: Siemens Nominal Low Fire O
11 Table 29: Safety Device Tests
15 VIII. Service, Maintenance, and Inspection
Table 30: Safety and Operating Controls
17
Table 31: General Troubleshooting
Appendix A: Sizing Gas Piping
17
Table 32: Maximum Gas Capacity Of Schedule 40
18
Pipe
19
Table 33: Equivalent Lengths Of Standard Pipe
Fittings And Valves
20
Table 34: Specific Gravity Correction Factors
Appendix B: Air Switch Adjustment
20
Appendix C: Venting Diagrams
21
Appendix D: Combustion Air Diagrams
Appendix E: Boiler Piping Diagrams
21
Appendix F: Water Flow Pressure Drops
Appendix G: Wiring Diagrams
21
Appendix H: Thermal Solutions (seller)
22
Appendix I: Installation & Startup Report
25
26
38
38
39
39
40
40
40
40
41
41
Arctic 1500-6000
Limited Warranty
41
43
44
44
2 47
50
51
58
59
60
60
61
61
62
63
64
65
70
72
97
98