Operation On Inclines; Shut Down Procedure; Towing - Terex PT-110 F Operation And Maintenance Manual

5.12 Operation on Inclines

By design, Compact Track Loaders are very stable on inclines. Machine weight is
distributed evenly throughout the chassis and the suspended undercarriage track
system provides excellent traction and floatation on nearly all surfaces.
Even with these capabilities, extreme caution should always be
exercised while operating the machine on an incline. Avoid operation on
steep inclines. Do not make sudden changes in direction, move slowly, and
always carry loads low to maximize machine stability.

5.13 Shut Down Procedure

1. Stop and lower any work attachments that may be coupled to
the machine.
2. Stop the machine in a safe location (on firm and level ground) where it is
protected from the elements and vandals.
3. Lower the lift arms until they rest on the frame stops.
4. Reduce engine RPM to a low idle.
5. Turn the ignition key counterclockwise to stop the engine, remove key.
6. Remove the seat belt and raise the lap bar.
7. Open the door (if equipped) and exit the machine using 3 points of contact
as described in the starting procedure in this section.

5.14 Towing

The primary purpose of a Compact Track Loader (CTL) is not that of a tow vehicle,
but if used as such, the following guidelines must be followed.
Maximum permitted tongue weight: ................... 500 lb.
Gross Combined Weight Rating (GCWR): ..............16,000 lb.
GCWR is the maximum allowable combined mass of the towing machine, operator, and cargo
in the tow vehicle, plus the mass of the trailer and cargo in the trailer.
• ALWAYS make sure any trailer is securely fastened to the supplied receiver
with standard 2" receiver mount hitch (appropriate for your application),
standard 5/8" pin and clip and safety chains (connected to chassis D-rings).
• ALWAYS use low range only (on machines equipped with two-speed).
• ALWAYS use extreme caution when towing on inclines, avoid steep inclines.
• ALWAYS operate with care ensuring the CTL is in command of any trailer.
• ALWAYS position the load on the trailer so there is a downward force
exerted on the hitch of the towing machine (not to exceed the above
rating). Arrange and secure loads low to maximize stability.
• ALWAYS park only on firm and level ground.
• NEVER use the CTL for towing on public roads.
• NEVER drive down steep inclines while towing to avoid "jack-knifing".
• NEVER carry passengers on trailers while towing.
• NEVER allow anyone between the CTL and trailer while moving.
67
5 OPERATION
PT-110/PT-110F US O&M
2095-479 2013-02