Hardwired Tracker Expansion Boards - DoorKing 1835 Owner's Manual

2.3.2 Tracker Expansion Boards (Hardwired)
The model 2358 Tracker Expansion Board (sold separately) allows you to expand the number of remote entry points that the
telephone entry system can control. One tracker expansion board is required for EACH remote entry point. Up to 24 boards can
be hardwired to the circuit board's Aux Terminal (First 12 boards connected to #7 - #9 and 12 more boards connected to #11 -
#13 if needed). Tracker expansion boards must have their own power source and the farthest board can be no more than 2000
ft from the telephone entry system. Each board must have a board address set on it to identify it to the telephone entry system
and if wiring more than 8 boards, some zone addresses need to be used for identification. The tracker expansion boards are
pre-programmed with many features but can be re-programmed for specific needs when desired. See Tracker Expansion Board
Manual 2358-065 for ALL wiring and programming options.
Telephone
Entry Connect card reader
using 4 conductor,
stranded with overall
System
shield. 18, 20, 22 or
24 gauge.
Circuit
Board
Red - NO circuit board connection.
Relay 0
Relay 2
Jumper
NO NC
NO NC C
Main Terminal
A 2C 2RY 1C 1NC 1NO BAT 16AC 16AC
Relay 1
Wire to 1C/1NO
Relay 2
"2RY" Contact is
set NO with Relay
2 Jumper on board.
Blue
Brown
Red - NO circuit board connection.
Relay 0
Main Door/Gate
IMPORTANT NOTE: ONLY use circuit
board 2358-010 Rev L or higher.
1835-065-D-5-17
Wiegand Card Reader
#6 - #9
Board Address 11
RF
SECURE
RF RF CODE CODE CODE
BOARD ADDRESS
DATA STATUS SENT GOOD BAD
ON
1
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
Blue 15
16
to 1NO
17
18
19
Brown
20
to 1C
ENT
ELEVATOR
1
2
3
Next 13 to 24 Boards
Aux Terminal #11 - #13
8 board addresses available per Aux terminal.
12 tracker boards Max per Aux terminal using zone addresses.
Aux Terminal #7 - #9
First 1 to 12 Boards
Connect card reader using
4 conductor, stranded with
overall shield.
18, 20, 22 or 24 gauge.
Board Address 3
RF
SECURE
BOARD ADDRESS RF RF CODE CODE CODE
DATA STATUS SENT GOOD BAD
ON
1
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
ENT
Lock Power
UL listed
OUTPUT ALARM AUX
2358-010
RELAY RELAY RELAY
NC NC NC
Door Lock
NO NO NO
#25 & #26
or Gate
Operator
21
22
23
24
25
26
27
28
29
30
31
Ground #32
32
33
34
RESET
16 VAC
20 VA
Board Power
UL listed
#33 & #34
Board Addresses 11-18
Board Addresses 3-10
Wiegand Card Reader
#6 - #9
Lock Power
UL listed
OUTPUT ALARM AUX
2358-010
RELAY RELAY RELAY
NC NC NC
Door Lock
NO NO NO
#25 & #26
or Gate
21 Operator
22
23
24
25
26
27
28
29
30
31
Ground #32
32
33
34
RESET
16 VAC
20 VA
Board Power
UL listed
#33 & #34
Wiegand Card Reader Lock Power
#6 - #9
UL listed
Board Address 12
RF OUTPUT ALARM AUX
SECURE
RF RF CODE CODE CODE RELAY RELAY RELAY
BOARD ADDRESS
DATA STATUS SENT GOOD BAD NC NC NC
ON
NO NO NO
1
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18 RESET
19
20
ENT
• The farthest board can be NO more than 2000 ft from the telephone entry system.
• Do not use twisted pair wire with 26, 30 and 31-Bit wiegand output format.
• Proper grounding is required! Ground wire should be a minimum 12 AWG.
Tracker Expansion Board Power: You may power up to four (4)
expansion boards from a single 16 VAC, 50 VA power transformer.
18 AWG wire up to 100 Ft.
16 AWG wire up to 200 Ft.
It is advisable to keep power wire runs as short as possible.
• The farthest board can be NO more than 2000 ft from the telephone entry system.
• Do not use twisted pair wire with 26, 30 and 31-Bit wiegand output format.
• Proper grounding is required! Ground wire should be a minimum 12 AWG.
Hardwire tracker expansion boards using 6 conductor, stranded with
overall shield. 18, 20, 22 or 24 gauge. Shield runs continuous. Float the
shield, DO NOT connect shield to 2358-010 board common.
Wiegand Card Reader Lock Power
#6 - #9 UL listed
Board Address 4
RF OUTPUT ALARM AUX
SECURE
RELAY RELAY RELAY
BOARD ADDRESS RF RF CODE CODE CODE
DATA STATUS SENT GOOD BAD
NC NC NC
ON
NO NO NO
1
0
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
RESET
19
20
ENT
2358-010
Door Lock
#25 & #26
or Gate
Operator
21
22
23
24
25
26
27
28
29
30
31
Ground #32
32
33
34
To Board
Addresses
16 VAC
20 VA
11 thru 18
Zone Addresses
must be used
Board Power when more than 8
boards are wired,
UL listed
12 boards MAX.
#33 & #34
2358-010
Door Lock
#25 & #26
or Gate
21 Operator
22
23
24
25
26
27
28
29
30
31 Ground #32
32
33
34
To Board
Addresses
16 VAC
20 VA 5 thru 10
Zone Addresses
must be used
Board Power when more than 8
boards are wired,
UL listed
12 boards MAX.
#33 & #34
21