Doosan D20S-5 Operation & Maintenance Manual page 73

Refueling Refueling
Gasoline or Diesel Engine Gasoline or Diesel Engine
Equipped Equipped
Explosive Explosive
refueling. refueling.
Do not smoke in refueling areas. Do not smoke in re
Lift truck should be refueled only at designated Lift truck should be refueled only at designated
safe locations. Safe outdoor locations are safe locations. Safe outdoor locations are
preferable to those indoors. preferable to those indoors.
Stop the engine and get off the lift truck during Stop the engine and get off the lift truck during
refueling. refueling.
Do not allow the lift truck to become low on fuel or Do not allow the lift truck to become low on fuel or
completely run out of fuel. Sediment or other completely run out of fuel. Sediment or other
impurities in the fuel tank could be drawn into the impurities in the fuel tank could be drawn into the
fuel system. This could result in difficult starting or fuel system. This could result in difficult starting or
damage to components. damage to components.
Fill the fuel tank at the end of each day of operation Fill the fuel tank at the end of each day of operation
to drive out moisture laden air and to prevent to drive out moisture laden air and to prevent
condensation. condensation.
In the cold weather, the moisture condensation can In the cold weather, the moisture condensation can
cause rust in the fuel system and hard starting due cause rust in the fuel system and hard starting due
to its freezing to its freezing
Do not fill the tank to the top. Fuel expands when it Do not fill the tank to the top. Fuel expands when it
gets warm and may overflow. gets warm and may
WARNING WARNING
fumes fumes may may be be present present
fueling areas.
NOTICE NOTICE
overflow.
-70- -70-
during during
1. 1. Park the lift truck only at a designated safe Park the lift truck only at a designated safe
location. Place the transmission in NEUTRAL. location. Place the transmission in NEUTRAL.
Lower the forks to the ground. Engage the Lower the forks to the ground. Engage the
parking brake. Stop the parking brake. Stop the engine.
2. 2. Open the filter cap. Open the filter cap.
3. 3. Fill the fuel tank slowly. Close the filter cap. Fill the fuel tank slowly. Close the filter cap.
If spillage occurs, wipe off excess fuel and was If spillage occurs, wipe off excess fuel and was
down area with water. down area with water.
NOTE: NOTE: Drain water and sediment from fuel tank as Drain water and sediment from fuel tank as
required by prevailing conditions. Also, required by prevailing conditions. Also,
drain water and sediment from the main drain water and sediment from the main
fuel storage tank weekly and before the fuel storage tank weekly and before the
tank is refilled. This will help prevent water tank is refilled. This will help prevent water
or sediment being pumped from the or sediment being pumped from the
storage tank into the lift truck fuel tank. k. storage tank into the lift truck fuel tan
Operation Section Operation Section
engine.