TOHATSU MFS 9.9E Owner's Manual page 64

64
INSPECTION AND MAINTENANCE
Description
Throttle cable
Throttle link*1
Shift/
Throttle
Shift cable
Shift link*1
Power trim & Tilt
Warning system*1
Stop switch
Meters
Bolt, nut
Sliding part
Other
/rotation part
Grease nipple
Outer equipment
Anode (engine)
Anode
(except for engine)
Top cowl/Latch
*1" " This procedure can be performed by end user (or dealer)
*2" " This procedure shall be carried out by the dealer.
ENON00030-1
Note
It is highly recommended that your outboard motor to go through complete inspection at 300
hours of use.
ENOM00091-A
Engine oil replacement
Engine oil mixed with dust or water will
10
dramatically shor ten the life of the
engine.
ENOW00091-1
You may be injured due to high engine tem-
peratures if you fill engine oil just after oper-
ation. Engine oil should be changed after the
engine has been cooled.
ENOW00092-1
Do not overfill engine oil, or engine oil
could leak and/or engine could be dam-
aged. If engine oil level is over upper limit
marks of dip stick, drain oil to level lower
than upper limit.
Inspection intervals
First 20 Every 50 Every 100
hours or 1 hours or 3 hours or 6
month months months
/ /
/
CAUTION
CAUTION
Every 200 Every 400
Inspection procedure
hours or 1 hours or 2
year year
Check and replace if necessary
Check and adjustment
Check and replace if necessary
Check and adjustment
Check /Replenish
Check
Check
Check
Retighten
Apply grease
Pump in grease
Check
Check and replace if necessary
Check /Replace if necessary
/
Check / Adjustment
Be sure that outboard motor is upright
when checking or changing oil.
Stop the engine immediately if low oil
pressure warning lamp or oil leak is found,
or engine could be severely damaged.
Consult your dealer.
Wipe off engine oil well immediately if
spilled and dispose of it in accordance
with local fire prevention and environ-
ment protection regulations.
ENOW00090-0
Use of engine oils that doesnot meet these
requirements will result in reducing engine
life, and other engine problems.
Remarks
Refer to P74
Refer to P75
Refer to P75
Refer to P73
Refer to P73
CAUTION