Transmission Oil Level - PREVOST X3-45 VIP 2017 Owner's Manual

8-6 Care and Maintenance
VOLVO D13 ENGINE OIL LEVEL DIPSTICK

TRANSMISSION OIL LEVEL

To prevent personal injury, do not service
transmission wearing loose clothing. Stand
clear of the engine and rotating components
while checking the oil level.
CAUTION
Do not mix fluid types or brands because of
possible incompatibility.
CAUTION
Use clean fluid and containers when filling
transmission. Never use containers that have
contained water or anti-freeze (Glycol).
Allison Automatic Transmission Oil Level
Transmission fluid level may be checked using
dipstick or transmission control pad display. For
more information on how to use the shift selector
display to check the transmission oil level, refer
to Appendix C under "Allison transmission oil
level check using the pushbutton shift selector"
in this manual.
The transmission fluid level dipstick is accessible
through the engine compartment rear door and
is located on the left side of the engine.
To check the transmission fluid level, a "cold
check" and a "hot check" must be performed. A
cold check must be made when the transmission
o
fluid is between 60
o
50 C).
NOTE
Perform the cold check first to verify the
transmission fluid level before performing the
hot check.
DANGER
o o
F and 120 F (16 C and
To prevent dirt and foreign matter from entering
the transmission, clean the end of the oil fill tube
before removing dipstick. To remove dipstick,
unscrew filler cap approximately three turns and
pull out dipstick.
01195
ENGINE L. H. SIDE

Cold Check
Run the engine until the transmission fluid
temperature is between 60
o
and 50 C). With the engine idling, make sure
the parking
transmission is in neutral (N). Remove and wipe
the dipstick with a clean cloth. Check oil level. If
the oil level is within the COLD RUN band, the oil
level is correct and a hot check can be
performed. If the oil level is on or below the lower
line of the COLD RUN band, add oil until the
level lies within the COLD RUN band. If the oil
level is above the COLD RUN band, drain oil
until the level is within the band.
TRANSMISSION FLUID LEVEL DIPSTICK (TYPICAL)
The oil level rises as oil temperature rises. Do
not add oil above the "cold run" band before
the transmission reaches 180
o
(82 C to 104
o
F and 120
brake is applied
CAUTION
o
C).
01189
o o
F (16 C
and the
07050
o o
F to 220 F