Safety; General Safety; Safety During Repair, Servicing And Maintenance; Operational Safety - B. Braun Aquaboss CCS Instructions For Use Manual

1.

Safety

1.1

General safety

The Aquaboss
®
ing to the latest technical standards and is fail-safe.
Improper or irregular use can put the operating personnel at risk. Therefore, the following is applicable:
• Read and carefully observe these operating instructions, especially the safety instructions.
• Keep the operating instructions near the CCS.
• Commissioning, operation and routine check is only to be carried out by authorized, trained and
B. Braun-instructed skilled workers. Electrical work is to be carried out only by authorized, trained and
instructed electricians.
• Without exception, all local safety and accident prevention regulations are applicable for operating the
system. These regulations must be observed and maintained at all times.
• Please observe instruction and warning signs.
• Consult a doctor immediately in the case of injuries, accidents or inflammation of the skin.
WARNING
1.2

Safety during repair, servicing and maintenance

1.2.1

Operational safety

WARNING
• If the product to be processed is damaging to the health, contact should be avoided. If contact does
occur, first-aid must be carried out on the premises.
• Do not modify, remove, bypass or bridge safety devices.
• Do not allow the pumps to run dry!
WARNING
1.2.2

Functional safety

When the housing is opened:
DANGER
Maintenance and repair work may only be carried out by authorized specialists.
NOTE
Rev. 2.8 Date 2019-02-04
Software version 1.00
Central Concentrate Supply CCS, abbreviated to CCS below, has been designed accord-
Hemodialysis concentrate can irritate the skin. It is not suitable for consumption. In the
event of skin or mucous membrane irritation, rinse thoroughly with water and consult
a physician.
If the system is at a standstill unexpectedly, the user should not change to a different
operating status immediately. Someone could have brought the system to a standstill for
manual intervention and forgotten to secure it against being switched back on. Unexpected
switch-on can lead to serious injuries.
In order to prevent patient hazards, maintenance, STK or service work should be done
during dialysis-free times.
Electrical shock
Dangerous voltage when control cabinet is open.
→ Switch off the device at the main switch and unplug from the mains.
Only original parts from B. Braun may be used. B. Braun does not accept any liability for
damage caused by spare parts, consumables or accessories that are not original B. Braun
parts.
Safety
Section 1 – Operating Instructions
CCS
Page 1-1