Volkswagen Golf 2015 Repair Manual page 58

Golf 2015 ➤ , Golf Variant 2015 ➤
Automatic Transmission - Edition 11.2014
Note
The connector on the transmission must not be damaged
♦
when removing and installing transmission. Replace the wiring
harness in the transmission if the connector gets damaged.
Refer to
⇒ 2.4 Solenoid Valve and Sensor Wiring Harness, Removing
and Installing , page 99
Be careful of the torque converter. It must be removed together
♦
with the transmission. Secure the torque converter for exam‐
ple with a wire -A- to prevent it from falling out.
The torque converter and transmission in the illustration may
♦
differ from the Original Part.
3.1.2 Transmission, Removing, Vehicles with
1.8L - 125 kW Engine
Short Description
The transmission is removed downward separately. The engine
remains in the vehicle.
Remove the battery, the battery tray, the engine cover and the air
filter housing »from above«. Engine with transmission are then
supported so that the left subframe mount can be removed.
Remove the noise insulation »from underneath«. Remove the
drive axles from the transmission and then remove the drive
axles. Lower the transmission with the transmission jack.
The subframe is not removed.
Special tools and workshop equipment required
♦ Engine Support Bridge - 10-222A-
♦ Engine Support Bridge - Engine Support 29 - 10-222A/29-
♦ Engine Support Bridge - Engine Support 18 - 10-222A/18-
♦ Engine/Gearbox Support Shackle (2 pc.) - 10-222A/12- (quan‐
tity 2)
♦ Transmission Support - Pins 29 - 3282/29-
♦ Transmission Support - 3282-
♦ Hose Clamps - Up To 25mm - 3094-
♦ Engine Support - Basic Set Square Pipe - T40091/1- (quantity
2)
♦ Engine Support - Basic Set Movable Joint - T40091/3- (quan‐
tity 2)
♦ Engine Support - Supplement Kit Spindle - T40093/3- (quan‐
tity 2) from the Engine Support - Supplement Kit - T40093A-
♦ Engine Support Brackets - T40093/3-6- (quantity 2)
♦ Engine Bung Set - VAS6122-
♦ Engine and Gearbox Jack - VAS6931- or Engine/Gearbox
Jack - VAG1383A-
♦ Socket - Sw15 - V/175-
54
Rep. Gr.37 - Controls, Housing
.