Checking Spark Plug Condition And Gap; Checking Engine Valve Clearance; Every 400 Hours Or 12000 Km; Changing Transmission Fluid - Kubota SIDEKICK RTV-XG850 Operator's Manual

EVERY 200 HOURS OR 6000 KM
8. Properly dispose of used filter.
(1) Engine oil filter
IMPORTANT :
• To prevent serious damage to the engine,
use only a KUBOTA genuine filter.
5. Checking spark plug condition
and gap
Remove the spark plugs, check condition, and reset the
gap or replace with new plugs as necessary.
1. Raise the cargo bed.
2. Push the safety support into the latch slot to lock
when the cargo is fully raised.
3. Before removing spark plugs, clean the area around
the base of the plug to keep dirt and debris out of
the engine.
4. Remove a bolt to remove the spark plug wires from
spark plugs.
5. Use a spark plug wrench to remove the spark
plugs.
(1) Spark plug
(2) Bolt
6. Remove plugs and check its condition.
Replace the plug if worn or reuse is questionable.
RTV-XG850
(3) Spark plug wire
7. Inspect spark plugs for cracked porcelain, pitted
electrodes, or other wear and damage. Replace the
spark plug if necessary.
NOTE :
• Do not clean the spark plug in a machine
using abrasive grit. Some grit could remain
in the spark plug and enter the engine
causing extensive wear and damage.
Recommended spark plug
8. Check the gap using a wire feeler gauge. Adjust the
gap from 0.8 to 1.1 mm (0.031 to 0.043 in.) by
carefully bending the ground electrode.
(A) from 0.8 to 1.1 mm (0.031 to 0.043 in.)
9. Reinstall the spark plug into the cylinder head.
Install the spark plug wires to spark plug.
Retightening torque
10. Release the safety support from the latch slot.
11. Slowly lower the cargo bed into the frame.

6. Checking engine valve clearance

If you do not have the proper tools and/or are not
mechanically proficient, consult your local KUBOTA
Dealer for this service.
EVERY 400 HOURS OR
12000 KM
Be sure to do the following servicing once every 400
hours or 12000 km, whichever comes first.

1. Changing transmission fluid

WARNING
To avoid serious injury or death:
• Be sure to stop the engine before changing the
oil.
PERIODIC SERVICE
NGK MR7J-9
10 to 12 N⋅m (7.4 to 8.9 lbf⋅ft)
73