Carrier AquaForce 30XA Series Installation Instructions Manual page 140

Table 5 — 30XA080-500 Electrical Data, Single Point (Standard Condenser Fan Motors)
UNIT VOLTAGE
NUMBER
UNIT OF
Supplied
V-Hz
30XA COND
(3 Ph)
Min Max FANS
230-60 207 253 6
200-60 187 220 6
080,
460-60 414 506 6
082
575-60 518 633 6
380-60 342 418 6
230-60 207 253 8
200-60 187 220 8
090,
460-60 414 506 8
092
575-60 518 633 8
380-60 342 418 8
230-60 207 253 8
200-60 187 220 8
100,
460-60 414 506 8
102
575-60 518 633 8
380-60 342 418 8
230-60 207 253 8
200-60 187 220 8
110,
460-60 414 506 8
112
575-60 518 633 8
380-60 342 418 8
230-60 207 253 8
200-60 187 220 8
120,
460-60 414 506 8
122
575-60 518 633 8
380-60 342 418 8
230-60 207 253 10
200-60 187 220 10
140,
460-60 414 506 10
142
575-60 518 633 10
380-60 342 418 10
230-60 207 253 10
200-60 187 220 10
160,
460-60 414 506 10
162
575-60 518 633 10
380-60 342 418 10
230-60 207 253 12
200-60 187 220 12
180,
460-60 414 506 12
182
575-60 518 633 12
380-60 342 418 12
230-60 207 253 12
200-60 187 220 12
200,
460-60 414 506 12
202
575-60 518 633 12
380-60 342 418 12
230-60 207 253 13
200-60 187 220 13
220,
460-60 414 506 13
222
575-60 518 633 13
380-60 342 418 13
230-60 207 253 13
200-60 187 220 13
240,
460-60 414 506 13
242
575-60 518 633 13
380-60 342 418 13
460-60 414 506 15
260,
575-60 518 633 15
262
380-60 342 418 15
460-60 414 506 16
280,
575-60 518 633 16
282
380-60 342 418 16
460-60 414 506 16
300,
575-60 518 633 16
302
380-60 342 418 16
460-60 414 506 18
325,
575-60 518 633 18
327
380-60 342 418 18
460-60 414 506 18
350,
575-60 518 633 18
352
380-60 342 418 18
460-60 414 506 20
400 575-60 518 633 20
380-60 342 418 20
LEGEND
ICF — Instantaneous Current Flow
MCA — Minimum Circuit Amps
MOCP — Maximum Overcurrent Protection
WD — Wye-Delta
XL — Across-the-Line
NO HYDRONIC PACKAGE
ICF Rec
MCA MOCP Fuse
WD XL
Size
315.5 400 484.2 1170.2 350
347.6 450 549.6 1338.6 400
157.7 200 242.1 585.1 175
121.2 150 191.9 465.9 150
183.5 250 289.7 704.7 225
334.0 450 499.1 1185.1 400 350.0
368.0 500 566.0 1355.0 450 385.7
167.0 225 249.6 592.6 200 175.0
128.5 175 197.8 471.8 150 134.9
194.5 250 298.6 713.6 225 204.2
364.6 500 536.7 1278.7 400 380.6
401.3 500 607.8 1461.8 450 419.0
182.3 250 268.4 639.4 200 190.3
139.5 175 211.7 508.7 175 145.9
212.7 250 321.7 770.7 250 222.4
405.7 500 536.7 — 450 421.7
446.2 600 607.8 — 500 463.9
202.4 250 268.4 639.4 225 210.4
155.5 200 211.7 508.7 175 161.9
236.4 300 321.7 770.7 300 246.1
438.6 600 569.6 — 500 454.6
482.2 600 643.8 — 600 499.9
218.4 300 284.4 655.4 250 226.4
168.4 225 224.5 521.5 200 174.8
255.3 350 340.6 789.6 300 265.0
534.7 800 796.7 — 700 550.7
588.5 800 906.1 — 700 606.2
267.3 400 398.4 1030.4 350 275.3
205.0 300 315.5 821.5 250 211.4
311.2 450 478.9 1243.9 350 320.9
621.1 800 997.6 — 700 637.1
682.8 1000 1136.1 — 800 700.5
309.7 450 498.4 1306.4 350 317.7
238.1 350 396.3 1042.3 300 244.5
361.1 500 598.9 1577.9 450 370.8
673.2 800 935.2 — 800
740.9 1000 1058.5 — 1000
336.6 450 467.6 1099.6 400
258.3 350 368.8 874.8 300
391.5 500 559.2 1324.2 450
769.6 1000 1146.0 — 1000
846.0 1000 1299.2 — 1000
383.9 500 572.6 1380.6 450
294.8 400 453.0 1099.0 350
447.2 600 685.0 1664.0 500
850.2 1200 1152.0 — 1000
935.1 1200 1305.9 — 1200
424.7 600 575.6 1383.6 500
326.3 450 455.4 1101.4 400
494.5 700 688.6 1667.6 600
910.0 1200 1211.8 — 1200
1001.1 1200 1371.8 — 1200
455.0 600 605.9 1413.9 600
349.6 450 478.7 1124.7 400
529.5 700 723.5 1702.5 600
516.5 700 777.6 1999.6 600
396.4 500 616.2 1594.2 450
600.2 800 933.9 2412.9 700
549.7 800 810.9 2032.9 700
422.1 600 641.9 1619.9 500
638.7 800 972.4 2451.4 800
610.9 800 810.9 2032.9 700
468.7 600 641.9 1619.9 600
710.3 1000 972.4 2451.4 800
624.3 800 885.5 2107.5 700
479.1 600 698.9 1676.9 600
724.7 1000 1058.4 2537.4 800
685.5 800 885.5 2107.5 800
525.7 700 698.9 1676.9 600
796.3 1000 1058.4 2537.4 1000
746.6 1000 1007.8 2229.8 1000
573.2 700 793.1 1771.1 700
867.6 1000 1201.3 2680.3 1000
5 HP PUMP, 3450 RPM
ICF Rec
MCA MOCP Fuse
WD XL
Size
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
450 515.1 1201.1 400
500 583.7 1372.7 450
225 257.6 600.6 200
175 204.2 478.2 150
250 308.3 723.3 225
500 552.7 1294.7 450
500 625.5 1479.5 500
250 276.4 647.4 225
175 218.1 515.1 175
300 331.3 780.3 250
500 552.7 — 500
600 625.5 — 600
250 276.4 647.4 250
225 218.1 515.1 200
300 331.3 780.3 300
600 585.6 — 500
600 661.5 — 600
300 292.4 663.4 250
225 230.9 527.9 200
350 350.3 799.3 300
800 812.7 — 700
800 923.8 — 700
400 406.4 1038.4 350
300 321.9 827.9 250
450 488.6 1253.6 400
800 1013.6 — 800
1000 1153.8 — 800
450 506.4 1314.4 400
350 402.7 1048.7 300
500 608.6 1587.6 450
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
NOTES:
1. Units are suitable for use on electrical systems where voltage supplied to the unit terminals
is not below or above the listed minimum and maximum limits. Maximum allowable phase
imbalance is: voltage, 2%; amps 10%.
2. Cooler heater is wired into the control circuit so it is always operable as long as the control
power supply disconnect is on, even if any safety device is open.
3. For MCA that is less than or equal to 380 amps, 3 conductors are required.
For MCA between 381 and 760 amps, 6 conductors are required.
For MCA between 761 and 1140 amps, 9 conductors are required.
For MCA between 1141 and 1520 amps, 12 conductors are required.
Calculation of conductors required is based on 75 C copper wire.
4. Wiring for main field supply must be rated 75 C minimum. Use copper for all units.
a. Incoming wire size range for the terminal block is no. 4 AWG (American Wire Gage) to
500 kcmil.
b. Incoming wire size range of non-fused disconnect with MCA up to 599.9 amps is 3/0 to
500 kcmil.
c. Incoming wire size range of non-fused disconnect with MCA from 600 to 799.9 amps is 1/
0 to 500 kcmil.
d. Incoming wire size range of non-fused disconnect with MCA from 800 to 1199.9 amps is
250 kcmil to 500 kcmil.
5. Data provided circuit 1/circuit 2 where there are two circuits.
6. Standard condenser fan motors are not used with sizes 30XA-401, 451, 476, and 501.
These sizes use high ambient temperature condenser fans.
140
7.5 HP PUMP, 3450 RPM
ICF Rec
MCA MOCP Fuse
WD XL
Size
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
357.2 450 522.3 1208.3 400
393.6 500 591.7 1380.7 450
178.6 225 261.2 604.2 200
137.7 175 207.0 481.0 150
208.6 250 312.6 727.6 250
387.8 500 559.9 1301.9 450
427.0 500 633.5 1487.5 500
193.9 250 280.0 651.0 225
148.8 200 220.9 517.9 175
226.7 300 335.7 784.7 250
428.9 600 559.9 — 500
471.9 600 633.5 — 600
214.0 300 280.0 651.0 250
164.8 225 220.9 517.9 200
250.4 350 335.7 784.7 300
461.8 600 592.8 — 600
507.8 600 669.4 — 600
230.0 300 296.0 667.0 300
177.7 225 233.8 530.8 200
269.4 350 354.7 803.7 300
557.9 800 819.9 — 700
614.1 800 931.8 — 700
278.9 400 410.0 1042.0 350
214.3 300 324.7 830.7 250
325.3 450 493.0 1258.0 400
644.3 800 1020.8 — 800
708.5 1000 1161.7 — 800
321.3 450 510.0 1318.0 400
247.4 350 405.6 1051.6 300
375.2 500 612.9 1591.9 450
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
— — — — —
CONTROL CIRCUIT
Voltage MCA
1 PH, and
60 Hz MOCP
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 40
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60
115 60