Fireback Installation - Travis Industries DVL EmberGlo GSR2 Insert Owner's Manual

52 Optional Equipment

Fireback Installation

Packing List

(1) Rear Fireback

(2) Side Firebacks
Installation
WARNING Turn off gas to the appliance and make sure it has fully cooled prior to conducting
service.
HANDLING THE FIREBACKS: The glass firebacks are fragile – especially the edges. Take care to prevent
contacting/scraping the glass against metal or rough surfaces. You may wish to lay out a blanket during
installation in case you need to set the firebacks down.
We recommend the use of gloves and safety glasses during the installation of the glass firebacks.
GLASS FIREBACK CLEANING
These firebacks require periodic cleaning. Do not use ammonia-based cleaners (this may cloud the glass).
We recommend ammonia-free glass cleaner (i.e. vinegar and water) to clean the fireback.
The rear fireback is rectangular and must be placed right side up. Lay the firebacks on a flat
surface prior to installing to verify the texture (brick, ledgestones) are aligned.
The firebacks are fragile, especially after being exposed to heat. Take care to prevent contacting/scraping the
firebacks against metal or rough surfaces.
NOTE On two-sided firebacks make sure the rear and sides patterns match.
NOTE On rear firebacks that have brick texture make sure the edge with the full brick is at the top.
1. Access the firebox (see Owner's Manual).
2. There are (2) fireback clips in the
firebox ceiling for DVS (1) on each
side and (3) for DVL – (1) on each
side and (1) in the back. Use a ¼"
nut driver to loosen the screws just
enough to allow the fireback clip to
move. The clip has a "keyhole" slot
on it. Slide the clip forward until it
can move freely over the head of the
screw. Tighten the screws so they
do not obstruct the installation of the
fireback panels in a later step.
© Travis Industries
(
for qualified installers only)

Fireback Clips (For Glass Firebacks ONLY)
NOTE: Comes as 1 piece – must be separated for
installation
GLASS FIREBACK WARNINGS
CERAMIC FIREBACK WARNINGS
Loosen Screw
Fireback Clip
9/17/2020 - 1536
TIghten Screw
DVL EG GSR2