SSANGYONG KYRON 2007.04 Manual page 211

01-46
0000-00
5) At least twice a year
▶ Power Steering System Reservoir Level
Check the power steering fluid level. Keep the power steering fluid at the proper level. Refer to
Section 4G, Power Steering System.
▶ Brake Master Cylinder Reservoir Level
Check the fluid and keep it at the proper level. A low fluid level can indicate worn disc brake
pads which may need to be serviced. Check the breather hole in the reservoir cover to be free
from dirt and check for an open passage.
▶ Weather-Strip Lubrication
Apply a thin film silicone grease using a clean cloth.
6) Each time the oil is changed
▶ Brake System Inspection
This inspection should be done when the wheels are removed for rotation. Inspect the lines and
the hoses for proper hookup, binding, leaks, cracks, chafing, etc. Inspect the disc brake pads
for wear. Inspect the rotors for surface condition. Inspect other brake parts, the parking brake,
etc., at the same time. Inspect the brakes more often if habit or conditions result in frequent
braking.
▶ Steering, Suspension and Front Drive Axle Boot And Seal Inspection
Inspect the front and rear suspension and the steering system for damaged, loose or missing
parts, signs of wear or lack of lubrication. Inspect the power steering line and the hoses for
proper hookup, binding, leaks, cracks, chafing, etc. Clean and inspect the drive axle boot and
seals for damage, tears or leakage. Replace the seals if necessary.
▶ Exhaust System Inspection
Inspect the complete system (including the catalytic converter if equipped). Inspect the body
near the exhaust system. Look for broken, damaged, missing, or out-ofposition parts as well as
open seams, holes, loose connections, or other conditions which could cause heat buildup in
the floor pan or could let exhaust fumes seep into the trunk or passenger compartment.
▶ Drain the Water from Fuel Filter
When the water level inside water separator in fuel filter exceeds a certain level, water
separator warning light comes on and buzzer sounds. Also, the driving force of the vehicle
decreases.
If these conditions occur, immediately drain the water from fuel filter & water separator.
▶ Hood Latch Operation
When opening the hood, note the operation of the secondary latch. It should keep the hood
from opening all the way when the primary latch is released. The hood must close firmly.
ENGINE D20DT
KYRON 2007.04