People and pets should be clear of coach while operating leveling system. Be sure to keep hands and other body parts clear of fluid leaks. Oil leaks in the LCI Level-Up® Motorhome Leveling System for Winnebago Industries may be under high pressure and can cause serious skin penetrating injuries.
12V DC electric motor drives a hydraulic pump that moves fluid through a system of hoses, fittings and jacks to level and stabilize the coach. Mechanical portions of the LCI Level-Up Motorhome Leveling System for Winnebago Industries are replaceable. Contact Lippert Components, Inc. to obtain replacement parts. See Page 19 for the Bill Of Materials list. Component Description Jacks A.
Page 5
ROD DIA. - 1.875 in. ROD DIA. - 2.25 in. 9” FOOTPAD- 9” FOOTPAD-STANDARD 12” FOOTPAD-STANDARD STANDARD 12” FOOTPAD-OPTION - 12” FOOTPAD-OPTION Part# - 117238 - Part# - 117238 Rev: 12.27.2017 Page 5 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
(Straight) Fittings are labeled w/ port assignments found stamped into the manifold. 140457 / 320521 (Elbow) Quick Disconnect for Flush & Fill 156846 143108 Return Fittings Rev: 12.27.2017 Page 6 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
Rear Jack Button - Activates both rear jacks in manual mode. Right Jack Button - Activates both right jacks in manual mode. Power Button - Turns leveling system on and off. Rev: 12.27.2017 Page 7 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
The Manual Air Bag Dump/Fill functions as follows: Set park brake. Scroll up twice to “MANUAL AIR CONTROL”. Press enter. Press REAR button (Fig. 5I) to dump, FRONT button (Fig. 5H) to fill. Rev: 12.27.2017 Page 8 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
For DIESEL UNITS with Air Bag Suspensions ONLY: NOTE: The leveling control will automatically program for air bag control. The option will not be present if no dump valve coil resistance is detected. Rev: 12.27.2017 Page 9 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
Occurs only in manual Use the manual functions to Excessive Angle mode when the angle of return coach to a more level the unit is too severe. condition. Rev: 12.27.2017 Page 10 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
NOTE: Refer to Component Description, page 4 and Fig. 5, page 7 for questions regarding location and functions of the LCI Level-Up Motorhome Leveling System for Winnebago Industries system. NOTE: Coach must be running and parking brake must be engaged for LCI Level-Up Motorhome Leveling System for Winnebago Industries to operate.
10. Visually inspect all jacks to ensure all footpads are touching the ground. Should one of the rear jack footpads not be touching the ground, press the corresponding LEFT or RIGHT arrow buttons to lower the non-compliant jack to the ground. Rev: 12.27.2017 Page 12 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
“AUTO RETRACT” can also be commenced by pushing and holding the "RETRACT" button (Fig. 5D) for 1 second. NOTE: In cold weather operation, always check to make sure all jacks, slide rooms, and steps are fully retracted before travel. Rev: 12.27.2017 Page 13 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
Do not overtighten override set screws, as this can damage the valves. Fig. 8 Fig. 7 Counterclockwise for normal operation Clockwise for manual override Rev: 12.27.2017 Page 14 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
Manual Override - Power System The LCI Level-Up Motorhome Leveling System for Winnebago Industries can be run with auxiliary power devices like cordless or power drills. In the event of electrical or system failure, this manual method of extending and retracting the jacks can be used.
"Jacks Down" Alarm The LCI Level-Up Motorhome Leveling System for Winnebago Industries is designed to sound an alarm and illuminate the control panel in the event of two (2) possible scenarios: A “RETRACT” hose leaks. The pressure holding the jacks in the retracted position falls to approximately 1500 psi.
Plumbing Diagram Right Front Jack Left Front Jack Orange - Retract Black - Extend Power Unit Retract Right Rear Jack Left Rear Jack Extend Rev: 12.27.2017 Page 18 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
141610 Elbow Fitting Fitting 162838 Washer 196994 Bolt *Jack quantities will either be 2 or 4 depending on OEM specified design. **Optional - Quantities will vary. Rev: 12.27.2017 Page 19 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
Replace fuse. Ignition not ON. Turn ignition ON. Auto level function does Error code "Unable to Move coach to a more level site. not finish. finish leveling." Rev: 12.27.2017 Page 20 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
" x 13 Hydraulic Power Unit Controller Touch Pad & Harness Auxiliary Harness Rear Sensor & Harness Power Unit Harness Contact us: Lippert Components Inc. - www.lci1.com/support - Phone: (574) 537-8900 - Email: customerservice@lci1.com Rev: 12.27.2017 Page 21 of 28...
Hydraulic Power Unit, Leveling Only 175249 Hydraulic Power Unit, Leveling Only 179327 12V DC Motor for Power Unit 161394 Motor Solenoid Contact us: Lippert Components Inc. - www.lci1.com/support - Phone: (574) 537-8900 - Email: customerservice@lci1.com Rev: 12.27.2017 Page 22 of 28...
Notes Rev: 12.27.2017 Page 27 LCI Level-Up Motorized Leveling Winnebago Industries up to 9-2015 Owner's...
Page 28
The contents of this manual are proprietar and copyright protected by Lippert Components, Inc. ("LCI"). LCI prohibits the copying or dissemination of portions of this manual unless prior written consent from an authorized LCI representative has been provided. Any unauthorized use shall void any applicable warranty.
Need help?
Do you have a question about the Level-Up and is the answer not in the manual?
Questions and answers