Battery; Charging Battery - Cushman Turf Truckster Parts & Maintenance Manual

6 MAINTENANCE

6.10 BATTERY ________________________________________________________________

Make absolutely certain the ignition switch is "Off" and
the key has been removed before servicing the battery.
!
CAUTION
Always use insulated tools, wear protective glasses or
goggles and protective clothing when working with
batteries. You must read and obey all battery
manufacturer's instructions.
Tighten cables securely to battery terminals and apply a
light coat of silicone dielectric grease to terminals and
cable ends to prevent corrosion. Keep vent caps and
terminal covers in place.
Keep the top of the battery clean and free of corrosion by
washing with a solution of baking soda and water. Rinse
with clean water.
Verify battery polarity before connecting or disconnecting
the battery cables.

6.11 CHARGING BATTERY _____________________________________________________

!
WARNING
Charge battery in a well ventilated area. Batteries
generate explosive gases. To prevent an explosion, keep
any device that may create sparks or flames away from
the battery.
To prevent injury, stand away from battery when the
charger is turned on. A damaged battery could explode.
1. Refer to Section 6.10. Read the Battery and Charger's
manual for specific instructions.
2. Whenever possible, remove the battery from the
vehicle before charging. If battery is not sealed, check
that the electrolyte covers the plates in all the cells.
Battery cables must be disconnected before using a "fast
charger" or damage to the alternator may result.
3. Make sure the charger is "Off". Then connect the
charger to the battery terminals as specified in the
charger's manual.
4. Always turn the charger "Off" before disconnecting
charger from the battery terminals.
GB-20
1. When installing the battery, always assemble the RED,
positive (+) battery cable first and the ground, BLACK,
negative (-) cable last.
2. When removing the battery, always remove the
ground, BLACK, negative (-) cable first and the RED,
positive (+) cable last.
3. Make sure battery is properly installed and secured to
the battery tray.
!
WARNING
Battery posts, terminals and related accessories
contain lead and lead compounds, chemicals known
to the State of California to cause cancer and
reproductive harm.
handling
.
Wash your hands after