Battery; Charging Battery - Cushman Turf Truckster 84069 Parts & Maintenance Manual

5 MAINTENANCE

5.10 BATTERY ________________________________________________________________

Make absolutely certain the ignition switch is OFF and
the key has been removed before servicing the battery.
!
CAUTION
Always use insulated tools, wear protective glasses or
goggles, and protective clothing when working with
batteries. You must read and obey all battery
manufacturer's instructions.
Tighten cables securely to battery terminals and apply a
light coat of silicone dielectric grease to terminals and
cable ends to prevent corrosion. Keep vent caps and
terminal covers in place.
Keep the top of the battery clean and free of corrosion by
washing battery with a solution of baking soda and water.
Rinse with clean water.
Verify battery polarity before connecting or disconnecting
the battery cables.

5.11 CHARGING BATTERY _____________________________________________________

!
WARNING
Charge battery in a well ventilated area. Batteries
generate explosive gases. To prevent an explosion
keep any device that may create sparks or flames
away from the battery.
To prevent injury stand away from battery when the
charger is turned on. A damaged battery could
explode.
1. Refer to Section 5.10. Read the Battery's and
Charger's manuals for specific instructions.
2. Whenever possible remove the battery from the
vehicle before charging. If battery is not sealed
check that the electrolyte covers the plates in all the
cells.
Battery cables must be disconnected before using a fast
charger or damage to the alternator may result.
3. Make sure the charger is Off. Then connect the
charger to the battery terminals as specified in the
charger's manual.
4. Always turn the charger Off before disconnecting
charger from the battery terminals.
en-22
1. When installing the battery, always assemble the
Positive (RED) (+) battery cable first and the
Negative (BLACK) (-) battery cable last.
2. When removing the battery, always remove the
Negative (BLACK) (-) battery cable first and Positive
(RED) (+) battery cable last.
3. Make sure battery is properly installed and secured
to the battery tray.
!
WARNING
Battery posts, terminals, and related accessories
contain lead and lead compounds, chemicals known
to the State of California to cause cancer and
reproductive harm.
handling.
Wash your hands after