Electrical - BOMBARDIER Rally 200 Operator's Manual

Air Filter Installation
Properly reinstall removed parts in the
reverse order of their removal.
Reinstall the air filter with the grey part
on top.
NOTE:
Check if the air filter broach
is properly located before installing air
filter.

Electrical

WARNING
Unless otherwise informed, al-
ways turn ignition switch to OFF
before performing any mainte-
nance or repair on electrical sys-
tem.
Battery
WARNING
Never charge a battery while in-
stalled in vehicle.
Clean battery post with a wire brush.
Apply dielectric grease (P/N 293 550
004) or an equivalent on post to pro-
tect against oxidation.
Removal
Disconnect BLACK (-) cable first then
RED (+) cable.
WARNING
Always respect this order for dis-
assembly; disconnect BLACK (-)
cable first. Electrolyte or fuel va-
pors can be present in engine
compartment and a spark may
ignite them and possibly cause
personal injuries.
Remove the holding strap.
Remove battery from vehicle being
careful not to tilt it so that electrolyte
flows out of vent tube.
Electrolyte is poisonous and dan-
gerous. Avoid contact with eyes,
skin and clothing. Wear protective
eyeglasses and a suitable pair of
non-absorbent gloves when re-
moving the battery by hand.
CAUTION:
spillage occur, immediately wash
off with a solution of baking soda
and water.
Cleaning
Clean battery, battery casing, cables
and battery posts using a solution of
baking soda and water.
Remove corrosion from battery cable
terminals and battery posts using a
firm wire brush. Battery top should be
cleaned by soft brush and any grease-
cutting soap or baking soda solution.
Installation
Reinstall battery in vehicle.
Connect RED (+) cable first then
BLACK (-) cable. Always connect
RED (+) cable first.
Fuse
If the fuse is damaged, replace it by
one of the same rating.
CAUTION:
rated fuse as this can cause severe
damage.
Fuse is located behind front right
shock, near coolant reservoir. Re-
move the cluster cover to allow an
access at the fuse holder.
_____________________
WARNING
Should any electrolyte
WARNING
Do not use a higher
95