Troubleshooting - Agria 3400 Operating Instructions Manual

6. Troubleshooting

Observe safety instructions! Have all serious malfunctions on the machine or engine repaired by your
W
agria workshop. They have the proper tools. Improper repairs can only add to the damage.
Problem Possible cause
Petrol engine:
Engine - Spark plug connector not connected
does not start - Choke is not pulled
- Engine shut-off switch is set to "0"
- Safety circuit is not set to start position
- Fuel tank empty or poor fuel
- Fuel line clogged
- Defective spark plug
- Engine too much fuel
("flooded engine")
- Engine-off-line defective
- Inleaked air due to loose caburetor
and suction line
Misfirings in - Engine running in CHOKE range
engine - Loose ignition cable
- Clogged fuel line or poor fuel
- Vent opening in fuel tank cap clogged
- Water or dirt in fuel system
- Air filter clogged
- Carburetor misadjusted
Excessive - Low engine oil level
temperature - Impaired cooling
in engine
- Air filter clogged
- Carburetor misadjusted
Misfirings in - Short firing intervals
engine - Incorrect idle mixture
at high speeds
Engine - Firing interval too long,
frequently defective spark plug
stalls - Carburetor misadjusted
in idle - Air filter clogged
agria-Two-Wheel Tractor 3400; 3400KL
Possible solution
Connect spark plug connector
Set choke lever to position CHOKE
Set engine shut-off switch to "I"
Set safety circuit to start position
Fill fresh fuel
Clean fuel line
Clean, adjust or exchange spark plug
Dry and clean spark plug and
start at full throttle
Check line and connections
Tighten attachment bolts
Set CHOKE lever to operating position
Fix ignition cable retaining device,
fit connector tightly on iginition cable,
fit connector tightly on spark plug
Clean fuel line,fill fresh fuel
Exchange fuel tank cap
Drain fuel and fill fresh fuel
Clean air filter or exchange
Re-adjust carburetor
Refill oil immediately
Clean cooling fan grid,
clean internal cooling fins
Clean air filter
Re-adjust carburetor
Adjust spark plug
Adjust carburetor
Adjust or replace spark plug
Re-adjust carburetor
Clean air filter
Page
50
50
31; 50
65
64
64
50
63
66
62
65
63
66
64
66
6
64
66
63
77