Superior DRC3035DEN Installation And Operation Instructions Manual page 38

Innovative Hearth Products
Superior DRT/C3000 Series Direct-Vent Gas Fireplaces
TM
NOTE: The supplied 15 ft of 2-conductor wire has one end of each conductor connected to the gas valve circuit and
the other end of each conductor placed loose inside the bottom compartment.
In millivolt systems, do NOT connect a wall switch to a 120 V power supply.
Figure 30: Wiring Diagram—Electronic Gas Valves (Traditional Models)
B
HI/LOW
SWITCH
B 2B 1B
BL
2 1
2A 1A
1
2
ON/OFF WALL
SWITCH
WIRING COLOR CODE
B = BLACK
BR = BROWN
GY = GRAY
PU = PURPLE
R = RED
Electronic Wiring
One of the following optional controls must be used:
•
•
•
See the Operation section on Page 54 for more details.
NOTE: Electronic models must be connected to the main power supply.
1. Route a 3-wire, 120 Vac, 60 Hz, 1 ph power supply to the fireplace junction box.
2. Remove the electrical inlet cover plate from the side of the unit by removing the plate's securing screws
3. If unit is not supplied with a strain relief, remove the cover plate knockout. Then, feed the power supply wire
4. Connect the black power supply wire to the lower outlet's red pigtail lead (Figure 32 and Figure 33). Connect the
5. Connect the ground supply wire to the pigtail lead attached to the outlet's green ground screw. Restrain the inlet
38
JUNCTION BOX
120V AC
B
HOT
W
NEUTRAL
G GROUND
BATTERY
R B
HOLDER
R
O
B
O
G
BL
W
BL = BLUE
G = GREEN
O = ORANGE
W = WHITE
Y = YELLOW
ON/OFF Wall Switch,
Thermostat, or
Remote Control.
(Table 8).
through the knockout opening and into the unit junction box.
white power supply wire to the outlet's common terminal.
power lead per NEC or local codes.
CAUTION
AC/DC
POWER
ADAPTOR
B
R
Y
G
O
O
SPLIT
FLOW
BL
G
B
W
R
BATTERY
HOLDER
B
HOOD
PROFLAME VALVE
PILOT TUBE
Y
SPARK WIRE CABLE
PILOT GROUND WIRE
Y
G
O
W
R
B
CPI SWITCH
OFF (O) = INTERMITTANT PILOT MODE
W ON (–) = STANDING PILOT MODE
R
BL
Installation
900285-00 05/2015
ELECTRONIC PILOT ASSEMBLY
IGNITER ROD
FLAME SENSOR
B
PILOT
B
SENSOR
CABLE
PROFLAME
DFC BOARD
W
DFC WIRE HARNESS
BL
G