Section 10-Tdx, Formula Tre, 2G Tarsys And Formula Pto Plus Batteries; Removing/Installing The Batteries From/Into The Wheelchair; Removing The Battery Door And Rear Shrouds - Invacare TDX 4 Owner's Operator And Maintenance Manual

SECTION 10—TDX, FORMULA TRE, 2G TARSYS AND FORMULA PTO PLUS BATTERIES
SECTION 10—TDX, FORMULA TRE,
2G TARSYS AND FORMULA PTO
PLUS BATTERIES
Read and understand the information and warnings in Handling and Replacing
Batteries on page 98 before performing these procedures.
Unless otherwise indicated, make sure power to the wheelchair is OFF before
performing these procedures.
After ANY adjustments, repair or service and BEFORE use, make sure all attaching
hardware is tightened securely - otherwise injury or damage may occur.
NOTE: If there is battery acid in the bottom of the battery tray or on the sides of the battery(ies),
apply baking soda to these areas to neutralize the battery acid. Before reinstalling the existing or
new battery(ies), clean the baking soda from the battery tray or battery(ies) being sure to avoid
contact with skin and eyes. Determine source of contamination. Never install/reinstall a battery
with a cracked or otherwise damaged case.
Removing/Installing the Batteries From/Into the
Wheelchair

Removing the Battery Door and Rear Shrouds

Place the wheelchair in a well ventilated area where work can be performed with-
out risking damage to carpeting or floor covering.
NOTE: For this procedure, refer to FIGURE 10.1 on page 107 and FIGURE 10.2 on page 108.
1. Verify the joystick ON/OFF switch is in the OFF position.
2. Remove the two thumb screws that secure the rear shroud to the wheelchair.
3. Remove the rear shroud from the wheelchair.
4. TRRO and TRBKTS Options Only - Perform the following steps:
A. Remove two thumb screws that secure the top controller shroud (FIGURE 10.2) to
the battery box.
B. Remove the top controller shroud from the battery box.
5. Formula PTO Plus ONLY - Tilt the PTO Plus back. Refer to Tilting the Seat Assembly
on page 96.
6. Remove both mounting screws from side of battery door.
TDX™ Wheelchairs
WARNING
CAUTION
106
Part No 1114809