Yamaha MM600D Service Manual page 15

Item
Check operation and fluid leakage.
Brake/
Adjust free play and/or replace pads if necessary.
parking brake
Replace brake fluid.
Check oil level.
Drive chain oil
Replace.
Check deflection.
Drive chain
Adjust if necessary.
Check wear and damage.
Skis and ski runners
Replace if necessary.
Check operation.
Steering system
Adjust toe-out if necessary.
Check damage.
Strap
Replace if necessary.
Check operation.
Lights
Replace bulbs if necessary.
Check engagement and shift speed.
Adjust if necessary.
Primary sheave
Check wear and damage.
Replace if necessary.
Lubricate with specified grease.
Lubricate with specified grease.
Secondary sheave
Adjust if necessary.
Steering column bearing Lubricate with specified grease.
Ski and front suspension Lubricate with specified grease.
Suspension component Lubricate with specified grease.
Lubricate with specified grease.
Parking brake cable end
and lever end/throttle
Check cable damage.
cable end
Replace if necessary.
Shroud latches Make sure the shroud latches are hooked.
Check tightness.
Fittings and fasteners
Repair if necessary.
Tool kit and recommended
Check proper placement.
equipment
NOTE:
Brake fluid replacement:
1. When disassembling the master cylinder or caliper cylinder, replace the brake fluid. Normally check the
brake fluid level and add the fluid as required.
2. On the inner parts of the master cylinder and caliper cylinder, replace the oil seals every two years.
3. Replace the brake hoses every four years, or if cracked or damaged.
PERIODIC MAINTENANCE TABLE
Remarks
2-2
INSP
ADJ
Initial
Pre- 1 month
operation or
check 800 km
(Daily) (500 mi)
(40 hr)
See NOTE.
Initial at 80 km (50 mi) and every 800 km
(500 mi) thereafter.
Whenever operating elevation is changed.
Whenever operating elevation is changed.
Every
Seasonally
or
3,200 km
(2,000 mi)
(160 hr)
2