Travis Industries Medium Flush Wood Hybrid Fyre Insert Manual page 17

WOOD HEATER DESCRIPTION
Appliance Manufacturer: Travis Industries, Inc.
Wood Stove Model: Medium Flush Wood Hybrid Fyre Insert
Type: Catalytic Hybrid Wood Burning Insert
WOOD HEATER INFORMATION
Materials of Construction: The unit is constructed primarily of mild steel. The firebox
is lined with fire brick that measures 4.0" x 9.0". The feed door has a 23.0 x 10.75 glass
panel and ¼" fiberglass rope gasket.
Air Introduction System: Air is introduced into three different areas of the fire chamber
and is controlled by one sliding control rod. Secondary air is introduced into the rear of
the fire box through the bottom, it is then channeled up into the secondary air tubes
located under the baffle. Air wash air is introduced through an opening in the bottom of
the fire box near the front. It is then channeled up to a manifold across the top of the
door, air is directed down across the glass and into the fire chamber. A lower primary air
orifice is mounted on the firebox floor near the loading door. Air is routed through the
bottom of the firebox and into the lower orifice manifold, it is then directed horizontally
into the coal bed near the front of the combustion chamber.
Combustion Control Mechanisms: Combustion air control mechanism is a sliding rod
with flat plates attached that cover and uncover air inlets when the rod is pushed in or
pulled out.
Combustor: Catalyst is a 25 cell per square inch ceramic manufactured by LSV
Ceramics CO.LTD, part number 174-01111. The component has an outside dimension of
20.75 x 3.125. An Interram gasket measuring 1/16" x 2" is wrapped around the outside
and then covered by a 20-gauge Stainless steel can.
Internal Baffles: A steel baffle is mounted near the top of the fire chamber, a ½" thick
ceramic blanket is placed on top. A sliding flue bypass is incorporated into the baffle,
when opened it allow products of combustion to bypass the catalyst and flow directly to
the flue outlet. When closed products of combustion are directed through the catalyst
mounted near the front of the baffle system.
Other Features: Two Fasco 90 CFM room air fans are offered as standard equipment;
tested model had a variable speed control mounted in the power supply cord.
Flue Outlet: The 6" diameter flue outlet is located at the rear of the top of the appliance.
WOOD HEATER OPERATING INSTRUCTIONS
Specific Written Instructions: See Section 4 of this report. All markings and
instruction materials were reviewed for content prior to printing.
17 of 236