Fuel System And Air Intake; Fuel System; Fuel Line; Fuel Pump / Fuel Filters - Polaris RZR 800 2013 Manual

FUEL SYSTEM AND AIR INTAKE

Fuel System

WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
Always stop the engine and refuel outdoors or in a well
ventilated area.
Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water
and change clothing.
Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness or
death in a short time.
Never drain the fuel when the engine is hot.
Severe burns may result.

Fuel Line

1. Check the quick-connect fuel line for signs of wear,
deterioration, damage or leakage. Replace if
necessary.
2. Be sure fuel line is routed and retained properly.
IMPORTANT: Make sure line is not kinked or
pinched.
3. Replace fuel line every two years.

Fuel Pump / Fuel Filters

The RZR 800 EFI engine uses a serviceable, high-
volume, high-pressure, fuel pump that includes a
preliminary filter and an internal fine filter located before
the pump regulator.
NOTE: Neither filter is servicable individually. Must
replace the fuel pump as an assembly.
NOTE: Refer to Chapter 4 for fuel pump replacement
and all other information related to the EFI System.
9924707 - 2013–2014 RZR 800 Service Manual
© Copyright 2013 Polaris Sales Inc.
MAINTENANCE
2
2.11