Fuel System And Air Intake; Fuel System - Ace: Warnings And Cautions; Fuel Tank Vent Line - Polaris ACE 900 2017 Service Manual

FUEL SYSTEM AND AIR INTAKE

FUEL SYSTEM - ACE: WARNINGS AND
CAUTIONS
WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
• Always stop the engine and refuel outdoors or in a well
ventilated area.
• Do not smoke or allow open flames or sparks in or
near the area where refueling is performed or where
gasoline is stored.
• Do not overfill the tank. Do not fill the tank neck.
• If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
• If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water and
change clothing.
• Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness or death in a short time.
• Never drain the fuel when the engine is hot. Severe
burns may result.
WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
Always stop the engine and refuel outdoors or in a well
ventilated area.
Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and waterand change
clothing.
Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness ordeath in a short time.
Never drain the fuel when the engine is hot.Severe
burns may result.
9929422 R02 - 2017-2019 ACE 900 Service Manual
© Copyright Polaris Industries Inc.

FUEL TANK VENT LINE

Symptoms of a restricted fuel tank vent include the
following: collapsing fuel tank, engine miss or hesitation,
loss of engine performance
temperatures.
1. Remove the seat and the engine compartment
access panel.
2. Check the fuel tank vent line for signs of wear,
deterioration or damage. Replace vent line if
necessary.
3. Be sure the vent line is routed properly and secured
with cable tie(s).
NOTICE
Make sure vent line is not kinked or pinched. The fuel
vent line will terminate into a 90° degree fitting in the
frame.
MAINTENANCE
or high exhaust
2
2.31