Table of Contents
Advertisement
TROUBLESHOOTING
CAUSES
Loading snowmobiles
onto trailers
Clutch malfunction
Slow, easy clutch
engagement
TROUBLESHOOTING (DET)
CAUSE OF DET ACTIVATION
Poor quality fuel
Low fuel/no fuel in tank
Water in fuel
Plugged fuel filter or tank pick-up
sock
Alcohol-based fuel additive used with
Ethanol fuel
Improper engine modifications
DIAGNOSTIC DISPLAY CODE DEFINITIONS
Open Load: There is a break in the wires that lead to the item listed in the chart
(injector, fuel pump, etc.), or the item has failed.
Short-to-Ground: The wire is shorted to ground between the electronic control
unit and the item listed in the chart.
Shorted Load: The wires leading to the item listed in the chart are shorted
together, or the item has shorted internally.
Short-to-Battery: The wire leading from the item listed in the chart to the
electronic control unit is shorted to a wire at battery voltage.
154
BELT WEAR/BURN DIAGNOSIS
Skis may gouge into trailers and prevent the
drivetrain from spinning properly. Use enough
speed to drive the snowmobile completely onto the
trailer. Push and pull it to finish loading if necessary.
Inspect clutch components. Your dealer can
perform this service.
Use fast, aggressive throttle to engage clutch.
SOLUTIONS
SOLUTION
Replace with higher quality fuel
Refuel with recommended fuel
Replace with recommended fuel
Your POLARIS dealer can perform
service
Do not add deicers or additives that
contain any form of alcohol while
using up to 10% Ethanol fuel
Do not modify the engine
Hide quick links:
Advertisement
Table of Contents
