Section 12-Batteries; Warnings For Handling And Replacing Batteries - Invacare Arrow RWD Service Manual

SECTION 12—BATTERIES
SECTION 12—BATTERIES

Warnings for Handling and Replacing Batteries

DANGER
Risk of Death or Serious Injury
Failure to observe these warnings can cause an electrical short resulting in death,
serious injury, or damage to the electrical system.
The POSITIVE (+) RED battery cable MUST connect to the POSITIVE (+) battery
terminal(s)/post(s).
The NEGATIVE (-) BLACK battery cable MUST connect to the NEGATIVE (-)
battery terminal(s)/post(s).
NEVER allow any of your tools and/or battery cable(s) to contact BOTH battery
post(s) at the same time. An electrical short may occur and serious injury or
damage may occur.
Install protective caps on positive and negative battery terminals.
Replace cable(s) immediately if cable(s) insulation becomes damaged.
DO NOT remove fuse or mounting hardware from POSITIVE (+) red battery cable
mounting screw.
WARNING
After ANY adjustments, repair or service and before use, make sure all attaching
hardware is tightened securely - otherwise injury or damage may occur.
Make sure power to the wheelchair is Off before performing these procedures.
The use of rubber gloves is recommended when working with batteries.
Invacare strongly recommends that battery installation and battery replacement
ALWAYS be done by a qualified technician.
22NF batteries weigh 37 pounds each. Use proper lifting techniques (lift with your
legs) to avoid injury.
GP24 batteries weigh 51 pounds each. Use proper lifting techniques (lift with your
legs) to avoid injury.
Use 22NF or GP24 batteries only. Failure to use the correct battery size and/or
voltage may cause damage to your wheelchair and give you unsatisfactory
performance.
ALWAYS use a battery lifting strap when lifting a battery. It is the most convenient
method and assures that the battery acid will not spill. It also helps to prolong the
life of the battery.
DO NOT tip the batteries. Keep the batteries in an upright position.
104
3G Storm Series® Wheelchairs Part No. 1104849