Hazard Warnings - Harsco Industrial SC-1500 Owner's Manual

N !
OTICE
The safety labels shown below are
affixed to your boiler. Although the
labels are of high quality, they may
become dislodged or unreadable
over time. Contact Harsco Industrial,
Patterson-Kelley at 570.476.7261 or
toll-free at 877.728.5351 for
replacements.
Gas may lose its odor. Proper gas
sensing equipment and procedures
should be used for leak checks.
Failure to detect gas leaks could
result in injury or death.
Bump Hazard from Overhead Ductwork and Piping
Injury Hazard! Install components with adequate vertical clearance.
Pressure Hazards
Pressure Hazard! Hot fluids. Install isolation valves on boiler water inlet and outlet.
Make sure isolation valves are closed before servicing boiler.
Pressure Hazard! Hot fluids. Annually test safety relief valve(s) for proper operation.
Do not operate boiler with faulty relief valve(s).
Training
Proper training is the best protection against accidents. It is
essential to read, understand, and follow the recommendations
of this manual before installing, operating, or servicing this
equipment. Failure to do so could result in fire or explosion and
serious injury, death, and/or property damage.
Operating and service personnel must be thoroughly familiar with
the basic construction of the
SC-4000 boilers, the use and locations of the controls, the
operation of the boilers, adjustment of their various mechanisms,
and all applicable safety precautions. If any of the provisions of
this manual are not fully and completely understood, contact
Harsco Industrial, Patterson-Kelley Technical
570.476.7261 or toll free at 877.728.5351.

Hazard Warnings

Electrical Hazards
Shock Hazard! Properly lockout/tagout the electrical
service and all other energy sources before working
on or near the boiler.
Shock Hazard! Do not spray water directly on this
boiler or any electrical components.
Electrical Hazard! Do not alter wiring connections.
Crush Hazards
Lifting Hazards! Use properly rated lifting
equipment to lift and position the boiler. The load is
unbalanced. Test the balance before lifting off the
floor. Do not allow personnel beneath the lifted
load. Refer to the approximate weights in the table.
Boiler Model
SC-1500
SC-2000
SC-3000
SC-4000
TM
P-K SONIC
T T T T echnical Service 1.877.728.5351 echnical Service 1.877.728.5351 echnical Service 1.877.728.5351 echnical Service 1.877.728.5351
SC-1500, SC-2000, SC-3000 and
Boiler Size Weight in Pounds
1,500,000 BTU
2,000,000 BTU
3,000,000 BTU
4,000,000 BTU
Gas Fired Boiler
Service at
1,450 lbs
1,450 lbs
1,850 lbs
1,900 lbs