Kubota ZG222A-AU Operator's Manual page 9

2 SAFE OPERATION
-
14. Before allowing other people to use your machine,
explain how to operate and have them read this
manual before operation.
15. In addition to the design and configuration of
equipment, hazard control and accident prevention
are dependent upon the awareness, concern and
prudence of personnel involved in the operation,
transport and maintenance of the equipment.
16. Keep the machine and attachments in good operating
condition and keep safety devices in place and in
proper working condition.
17. Do not modify the machine. Unauthorized modification
may affect the function of the machine, which may
result in personal injury.
18. Use only implements approved by KUBOTA. Use
proper ballast to front or rear of machine to reduce the
risk of upsets. Follow
procedures, specified in the manuals with equipment.
19. Keep your machine clean. Accumulations of dirt,
grease, and trash can contribute to fires and lead to
personal injury.
20. The exhaust gas from the muffler is very hot. To
prevent fire, do not expose dry grass, mowed grass, oil
and any other combustible materials to exhaust gas.
Use a spark arrester where required. Also keep the
engine and muffler clean all the time.
2. OPERATING
C Starting
1. Always sit in the operator's seat when starting engine
or operating levers or controls.
2. Before starting the engine make sure that the motion
control levers are in neutral lock, the parking brake is
applied, and Power Take Off (PTO) is disengaged
(OFF).
3. Do not start engine by shorting across starter
terminals. The machine may start in gear and move if
normal starting circuitry is bypassed.
4. Do not operate or idle engine in a non-ventilated area.
Carbon monoxide gas is colorless, odorless, and
deadly.
5. Do not start engine while tilting deck.
6. Check before each use that operator presence
controls are functioning correctly. Test safety systems.
(See "Safety Devices" in "EVERY 50 HOURS" in
"PERIODIC SERVICE" section.)
Do not operate unless they are functioning correctly.
C Working
1. Do not turn sharply when driving at high speed.
2. To avoid tip over, slow down when turning on uneven
terrain or before stopping.
3. Do not operate near ditches, holes, embankments, or
other terrain, which may collapse under the machine
weight. The risk of machine tip over increases when
the ground is loose or wet.
the "Safe Operation"
4. Park the machine on a firm and level surface.
5. Watch where you are going at all times. Watch for and
avoid obstacles. Be alert at curbs, near trees, and
other obstructions and hidden hazards.
6. Know what is behind you before backing up. Look to
the rear before and when backing. Do not mow while
in reverse unless absolutely necessary and make sure
the area immediately behind you is clear of
obstructions or holes and small children. Use extra
caution when machine is equipped with Grass
Catcher. Your view to the rear is restricted.
7. When working in groups, always let others know what
you are doing ahead of time.
8. Do not drive machine on streets or highways. Watch
for traffic when you cross roads or operate near roads.
9. Be aware of the mower discharge direction and do not
point it at anyone.
10. When using any attachments, never direct discharge
material toward bystanders. Do not allow anyone near
the attachments while in operation.
Do not mow when bystanders are present in the
mowing area.
11. To reduce fire hazards, keep the engine exhaust area
free of grass or leaves.
12. Be sure rotating blades and engine are stopped and
the key is removed before placing hands or feet near
blades and cleaning blockages or unclogging chute.
13. Shut the engine off and wait for all movement to stop
before removing grass catcher or unclogging chute.
14. Watch the temperature gauge and maintain all
screens to avoid overheating conditions.
15. Always inspect the mower for damage after striking a
foreign object. Repair or replace any damaged parts
before restarting.
16. Operate during daylight or in bright artificial light.
C Children
Tragic accidents can occur if the operator is not alert to
the presence of children. Children are attracted to the
machine and mowing activity.
Never assume that children will remain where you last
saw them.
1. Keep children out of the mowing area and under the
watchful care of another responsible adult.
2. Be alert and turn machine off if children enter the area.
3. Before and when backing, look behind and down for
small children.
4. Never carry children. There is no safe place for them
to ride. They may fall off and be seriously injured or
interfere with safe machine operation.
5. Never allow children to operate the machine, even
under adult supervision.
6. Use extra care when approaching blind corners,
shrubs, trees, or other obstructions that might hide
children from sight.
7. Do not mow in reverse unless it is absolutely
necessary and make sure area to the rear is clear of
children before doing so.