CORRECT CRAFT Super Sport User Manual page 74

CAUTION: WHEN REINSTALLING THE BATTERY AFTER
WINTERIZATION, BE SURE IT IS FULLY CHARGED. MAKE
CERTAIN TO CONNECT THE POSITIVE CABLE TO THE POSITIVE
BATTERY TERMINAL AND THE NEGATIVE CABLE TO THE
NEGATIVE BATTERY TERMINAL. DO NOT REVERSE THE
CONNECTIONS.
Winter Storage of Batteries
Battery companies are not responsible for battery damage either in winter
storage or in dealer stock if the following instruction are not followed.
Remove battery from it's installation as soon as possible. Be sure vent caps
are tight. Wash the battery with a diluted ammonia or soda solution to
neutralize any acid present. Flush with clean water to remove grease, sulfate
and dirt from the top surface. Wipe off all excess water with clean rags.
Check water level, making sure that the battery plates are covered with
water.
When adding distilled water to the battery, be extremely careful not to fill
more than 3/16" (4.8mm) above the perforated baffles inside the battery.
Battery solution or electrolyte expands from the heat caused by charging. If
the water level is more than the 3/16" (4.8mm) , the electrolyte will overflow
during charging.
Grease terminal posts well with cup grease or multipurpose lubricant and
store the battery in a cool, dry place. Remove battery from storage every 30
- 45 days, check water level and put on charge for 5 - 6 hours at 6 amps.
DO NOT FAST CHARGE !
RECOMMISSIONING
Assemble water pump and reinstall on engine.
Remove spark plugs and rotate engine by hand several times to remove oil
from the cylinders. Do not use the starter to rotate the engine. Replace all
the plugs and connect plug wires to the correct plugs.
Install battery, making sure it is fully charged. Clean and lubricate terminals.
Check cooling system to be sure all hoses are the water pump are properly
attached.
Re-adjust alternator drive belt and water pump drive belt tension.
8.18
CAUTION: WHEN REINSTALLING THE BATTERY AFTER
WINTERIZATION, BE SURE IT IS FULLY CHARGED. MAKE
CERTAIN TO CONNECT THE POSITIVE CABLE TO THE POSITIVE
BATTERY TERMINAL AND THE NEGATIVE CABLE TO THE
NEGATIVE BATTERY TERMINAL. DO NOT REVERSE THE
CONNECTIONS.
Winter Storage of Batteries
Battery companies are not responsible for battery damage either in winter
storage or in dealer stock if the following instruction are not followed.
Remove battery from it's installation as soon as possible. Be sure vent caps
are tight. Wash the battery with a diluted ammonia or soda solution to
neutralize any acid present. Flush with clean water to remove grease, sulfate
and dirt from the top surface. Wipe off all excess water with clean rags.
Check water level, making sure that the battery plates are covered with
water.
When adding distilled water to the battery, be extremely careful not to fill
more than 3/16" (4.8mm) above the perforated baffles inside the battery.
Battery solution or electrolyte expands from the heat caused by charging. If
the water level is more than the 3/16" (4.8mm) , the electrolyte will overflow
during charging.
Grease terminal posts well with cup grease or multipurpose lubricant and
store the battery in a cool, dry place. Remove battery from storage every 30
- 45 days, check water level and put on charge for 5 - 6 hours at 6 amps.
DO NOT FAST CHARGE !
RECOMMISSIONING
Assemble water pump and reinstall on engine.
Remove spark plugs and rotate engine by hand several times to remove oil
from the cylinders. Do not use the starter to rotate the engine. Replace all
the plugs and connect plug wires to the correct plugs.
Install battery, making sure it is fully charged. Clean and lubricate terminals.
Check cooling system to be sure all hoses are the water pump are properly
attached.
Re-adjust alternator drive belt and water pump drive belt tension.
8.18