Procom FBN280RHAC Series Owner's Operation And Installation Manual

Remote control fireplace; thermostat control fireplace

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

FBN280RHAC Series

FBL280RHAC Series

FBN280TAC Series

FBL280TAC Series

WARNING:

fired heater. It uses air (oxygen) f ro m t h e r o o m

i n

w h i c h

i t i s installed. Provisions for ad-

equate combustion and ventilation air must b e

p r o vid ed . R e f er t o A ir F o r Combustion and

Ventilation section on page 5 of this manual.

Continental Appliance Inc./U.S. Office

5 Musick

4600 Highlands Parkway S.E.

Irvine

Suite# D/E

CA 92618

Smyrna GA 30082

CUSTOMER CARE: 1-877-866-5989

Remote Control Fireplace

Thermostat Control Fireplace

This is an unvented gas-

OW N E R ' S O P E R AT I O N A N D

INSTALLATION MANUAL

WARNING

is not followed exactly, a f i r e o r e x p l o s i o n m a y

r e s u l t causing property damage, personal injury,

or loss of life.

Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any

other appliance.

WHAT TO DO IF YOU SMELL GAS

Do not try to light any appliance.

Do not touch any electrical switch;do not use any

phone in your building.

Immediately call

neighbor's phone. Follow the gas supplier's

instructions.

If you

cannot reach your gas supplier, call

the fire department.

Installation and service must be performed by a

qualified installer, service agency, or the gas

supplier.

WARNING

alteration, service or maintenance can cause injury

or property damage. Refer to this manual for correct

installation and operational procedures. For assis-

tance or additional information consult a qualified

installer, service agency, or gas supplier.

This appliance may be installed in an aftermarket*,

permanently located, manufactured (mo b ile) h o me,

where not prohibited by local codes.

This appliance is only for use with the type of gas

indicated on the rating plate. This appliance is not

convertible for use with other gases.

*Aftermarket: Completion of sale, not for purpose of resale,

from the manufacturer.

Consumer: Please retain these instructions for future

use.

InstaIIer: Please Leave these instructions with the con-

sumer

www.usaprocom.com

FULL SIZE VENT-FREE

FIREPLACE

If the information in this manual

your gas supplier from a

: Improper installation, adjustment,

PC-FBL035-01HR/T-0607

Table of Contents

Need help?

Do you have a question about the FBN280RHAC Series and is the answer not in the manual?

Questions and answers

Summary of Contents for Procom FBN280RHAC Series

Page 1 WHAT TO DO IF YOU SMELL GAS Do not try to light any appliance. Do not touch any electrical switch;do not use any FBN280RHAC Series Remote Control Fireplace phone in your building. FBL280RHAC Series Immediately call...
Page 2: Table Of Contents
Table of Contents Make certain you read and understand Important Safety Information ....2 WARNING all warnings. Keep this manual for Models FBN280 are equipped for Natu- Air for Combustion and Ventilation..5 reference. It is your guide to safe ral gas. F ield c on versio n is n ot Installation..........7 and proper operation of this heater.
Page 3: Safety Information
SAFETY INFORMATION 17. Do not operate heater if any log State of Massachusetts: The instal- is broken. Do not operate heater Continued lation must be made by a licensed if any log is chipped (dime-sized plumber or gas fitter in the Common- or larger).of 4,500 feet could 8.
Page 4 LOCAL CODES UNPACKING lnstall and use heater with care. 1. Remove top inner pack. F o l lo w al l lo c a l c o d e s. In t h e 2. Tilt carton so that fireplace is upright. absence of local codes, use the 3.
Page 5: Air For Combustion And Ventilation
AIR FOR COMBUSTION AND VENTILATION Confined and Unconfined Space Unusually Tight Construction WARNING : This heater The National Fuel Gas Code, ANS The air that leaks around doors and shall not be installed in a confined windows may provide enough fresh Z223.1 defines a confined space as a space or unusually tight construc- air for combustion and ventilation.
Page 6 3. Add the Btu/Hr of all fuel burning appliances in the space. Vent-free heater Btu/Hr Example: Gas water heater* Btu/Hr Gas water heater 30,000 Btu/Hr Gas furnace Btu/Hr Vent-free heater 26,000 Btu/Hr Vented gas heater Btu/Hr Total 56,000 Btu/Hr Gas heater logs Btu/Hr Other gas appliances* + Btu/Hr...
Page 7: Installation
INSTALLATION NOTICE: This heater is intended for use as supplemen- tal heat. Use this heater along with your primary heating system. Do not install this heater as your primary heat source. If you have a central heating system, you run system's circulating blower while using heater.
Page 8: Connecting To Gas Supply
INSTALLATION Continued CONNECTING TO GAS The installer must supply an external IMPORTANT: Inst all equ ipment SUPPLY regulator. The external regulator will shutoff valve in an accessible location. reduce incoming gas pressure. You The equipment shutoff valve is for WARNING: A qualified techni- must reduce incoming gas pressure turning on or shutting off the gas to cian...
Page 9 INSTALLATION Continued CHECKING GAS CON- NECTIONS WARNING: Test all gas piping CAUTION: Make sure external WARNING: Never use an open and connections for leaks after regulator has been installed be- flame to check for a leak. Apply a installing or servicing. Correct all tween gas supply and heater.
Page 10: Installing Logs
INSTALLATION Continued INSTALLING LOGS WARNING: Failure to position the parts in accordance with these diagrams or failure to use only parts may result in property damage or personal injury. CAUTION: After installation and periodically thereafter, check to en- sure that no flame comes in Figure 10 -Installing Log Set contact with any log.
Page 11: Operating Heater, Rha Models
D. Do not use this appliance if any OPERATING HEATER OPERATIONS OF part has been under water. Imme- FOR YOUR SAFETY REMOTE TRANSMITTER diately call a qualified service techni- RHA Series Models cian to inspect the appliance and to 1. Install three AAA batteries in the replace any part of the control system battery holder.
Page 12: Cleaning & Maintenance
OPERATING HEATER Continued Set temperature: Press “Temp” 8. Keep Control Knob depressed for MANUAL OVERRIDE button, then press to set desired ▼ ten (10) seconds after lighting CONTROL SYSTEM OPERATING room temperature. Burner will operate pilot. If pilot goes out, repeat steps INSTRUCTIONS to maintain set room temperature.
Page 13 PILOT FLAME PATTERN DISCONNECT FAN F igu re 15 sh ow s a c o rrec t p ilo t Remove screws from the fan flame pattern. Figure 16 shows an bracket panel , pull the fan bracket incorrect pilot flame pattern. The panel out to remove.
Page 14: Cleaning And Maintenance
CLEANING AND MAINTENANCE Continued Exterior inlet hole about two inches from Use a soft cloth dampened with a where the pilot flame comes out of mild soap and water mixture. Wipe the pilot assembly (see Figure 22). the cabinet to remove dust. With the unit off, lightly blow air LOGS through the air inlet hole.
Page 15: Specifications
SPECIFICATIONS FBN280TAC FBL280TAC FBN280RHAC FBL280RHAC Btu(Variable) 28000 28000 Gas Type LP Gas Natural Gas Ignition Piezo/Automatic Piezo/Automatic Manifold Pressure 8"W.C. 3"W.C. Inlet Gas Pressure (In. of water)* Maximum 14" 10.5" Minimum 11" 5" Dimensions, Inches (H × W × D) 36 1/4”...
Page 16: Troubleshooting
7. Check the wine and make wine 7. W ire is not correct or loosen correct. 8. Contact dealer or procom. 8 Gas valve is damage 1. Hand tighten until snug, then 1. Thermocouple connection loose ODS/pilot lights but flame is continu- at control board tighten 1/4 turn more.
Page 17: Replacement Parts
If they can’t supply original re- of your heater parts. This will protect your warranty placement part(s) call ProCom’s toll free How heater was malfunctioning coverage for parts replaced under number at (1-877-886-5989) for referral Type of gas used (propane/LP or warranty.
Page 18: Parts List
PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 17 FBN280TAC of this manual. FBL280TAC QUALITY KEY NO PART NUMBER DESCRIPTION LP NG SIT545-218 T-STAT VALVE SIT545-200 T-STAT VALVE NRV81F1-3...
Page 19 PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 17 FBN280TAC of this manual. FBL280TAC QUALITY KEY NO PART NUMBER DESCRIPTION LP NG BB26000 LOGS TOP PANEL FB280AC6-01 SIDE PANEL FB280AC6-03...
Page 20 PARTS LIST This list contains replaceable parts used in your heater. When ordering FBN280RHA parts, follow the instructions listed under Replacement Parts on page 17 of this manual. FBL280RHA QUALITY KEY NO PART NUMBER DESCRIPTION LP NG OVERRIDE CONTROL SYSTEM NV2020-22* T-STAT VALVE BRACKET BL015-03RA...
Page 21 PARTS LIST This list contains replaceable parts used in your heater. When ordering FBN280RHA parts, follow the instructions listed under Replacement Parts on page 17 of this manual. FBL280RHA Key No. Part Number Description QL016-03R BLOWER MOUNT PANEL PF06-Y JLF-F BLOWER NAYB03-00 CONTROL CABINET ASSEMBLE...
Page 22: Installation Instructions
INSTALLATION INSTRUCTIONS For CORNER SURROUND AND HEARTH READ INSTRUCTIONS BEFORE BEGINNING INSTALLATION. Check to see that you have the following. If any part or parts are missing, contact the dealer where you bought the sur- round and hearth. TOOLS REQUIRED: Measuring Tape, Pencil, Level, #2 Phillips Screw Driver, Hammer, Electric Drill, 5/6"...
Page 23 6. Place the assembled fireplace on the middle where it is 30” from the corner and form a 45 degree angle to each side wall. Move the assembled surround to the corner, with side panels close to side walls. Move the fireplace to where it can prop- erly attach the surround.

This manual is also suitable for:

Fbl280rhac series Fbn280tac series Fbl280tac series Fbn280rha series Fbl280rha series Fbn280ta series ... Show all

Procom FBN280RHAC Series Owner's Operation And Installation Manual

Quick Links

Need help?

Questions and answers

Related Manuals for Procom FBN280RHAC Series

Summary of Contents for Procom FBN280RHAC Series

This manual is also suitable for:

Table of Contents