General Performance Data - Modine Manufacturing PDP Installation And Service Manual

generAl PerformAnCe dATA

Table 16.1 - Performance - Propeller (PdP) and Blower (BdP) models ➀ ➁
PdP 150 PdP 175 PdP 200 PdP 250 PdP 300 PdP 350 PdP 400 BdP 150 BdP 175 BdP 200 BdP 250 BdP 300 BdP 350 BdP 400
Btu/hr. Input 150,000 175,000
Btu/hr. output 120,000 140,000
entering Airflow 2180
(Cfm)
Cfm range –
Air Temp. rise (°f)
51
max. mounting hgt.
(ft) ➂ 16
heat Throw (ft) ➂
(max. mtg. hgt.) 55
motor Type PSC
115/60/1 (PC01) 1/8
230/60/1 (PC02) 1/8
hP
208/60/1 (PC03) N/A
Table 16.2 - electrical details Propeller units
Power
supply unit
voltage voltage
voltage Phase voltage Phase
115 1 115 1
208 1 115 1
208 1 208 1
208 3 115 1
230 1 115 1
230 1 230 1
230 3 115 1
460 3 115 1
575 3 115 1
Table 16.4 - motor data and Total unit Power requirements - Propeller models ➀
unit voltage 115/60/1
supply voltage 115/60/1
mtr. mtr.
hP
Amps rpm Amps
1/8 2.3 1625
1/6 2.7 1075
1/3
5.4 1075
1/2
7.5 1075
3/4 8.8 1125
Table 16.5 - motor data and Total unit Power requirements - Blower models ➀
voltage 115/60/1
motor motor
hP rpm Amps
1/4
1725 3.7
1/3 1725 5.0
1/2 1725 8.0
3/4 1725 11.0
1
1725 13.4
1-1/2
1725 15.2
2
1725 ---
3 1725 ---
5 1725 ---
➀ All motors are totally enclosed and all single phase motors have built-in thermal overload protection.
➁ Ratings shown are for elevations up to 2,000 ft. For elevations above 2,000', ratings should be reduced at the rate of 4% for each 1,000' above sea level.
(In Canada see rating plate.) Reduction of ratings requires use of a high altitude kit.
➂ Data taken at 55°F air temperature rise. At 65°F ambient and unit fired at full-rated input. Mounting height as measured from bottom of unit, and without deflector hoods.
A transformer may not be required. 115V/1φ power may be obtained from the following electrical distribution systems: 230/1φ 3-wire, 230/3φ
➃
4-wire, 208/3φ 4-wire and 208/1φ 3-wire (from 208V wye connected transformer). Please consult the job site electrician to determine applicability.
Unit power code must match building supply voltage, control voltage must match unit power.
➄
For CSA Canada certification, step down transformer may be required to be factory installed (Blower Models Only).
➅
16
200,000 250,000 300,000
160,000 200,000 240,000
2550 2870 3700 4460
– – – –
51 52 50 50
17 15 19 21
59 51 67 74
PSC PSC PSC PSC
1/6 1/6 1/3 1/2
1/6 1/6 1/3 1/2
1/6 1/6 N/A N/A
Additional
factory
Control
field Installed
Installed
Code
selected Transformers
Transformer
30,63,85,87 115V to 24V
30,63,85,87 115V to 24V 208V to 115V
31,64,86,88 208V to 24V
30,63,85,87 115V to 24V 208V to 115V ➃
30,63,85,87 115V to 24V 208V to 115V ➃
31,64,86,88 230V to 24V
30,63,85,87 115V to 24V 230V to 115V ➃
30,63,85,87 115V to 24V 460V to 115V
30,63,85,87 115V to 24V 575V to 115V
115/60/1 With use of Transformer
208v 230v
Total KvA Total KvA
req. Amps req. Amps req. Amps req. Amps Amps rpm Amps Amps rPm Amps
4.0 0.50 2.4 0.50
5.1 1.00 4.81 0.75
7.7 1.00 4.81 1.00
9.8 1.50 7.2 1.50
11.1 1.50 7.2 1.50
230/60/1
Total motor Total
Amps Amps Amps
6.0 2.7 4.0
7.3 2.5 3.8
10.3 4.0 5.3
13.3 5.4 6.7
15.7 6.7 8.0
17.5 7.6 8.9
--- --- ---
--- --- ---
--- --- ---
model number
350,000 400,000 150,000
280,000 320,000 120,000
4870 5440 2020
– –
1587-2778 1852-3241 2116-3704 2646-4630 3175-5556 3704-6481 4233-6584
53 54 40-70
20 19 14
70 69 49
PSC PSC
3/4 3/4
3/4 3/4
N/A N/A
Table 16.3 - electrical details Blower units
Power
supply
voltage
voltage Phase voltage Phase
none 115 1
208 1
none 208 3
230 1
230 3
none 460 ➄ 3
460 3
575 ➄ 3
575 3
460v 575v
Total KvA Total KvA
2.17 0.50 1.09 0.50
3.26 0.75 1.63 0.75
4.35 1.00 2.17 1.00
6.52 1.50 3.26 1.50
6.52 1.50 3.26 1.50
208/60/3 230/60/3
motor Total motor
Amps Amps Amps
1.3 2.6 1.2
1.2 2.5 1.2
2.2 3.5 2.1
2.8 4.1 2.7
3.6 4.9 3.5
4.8 6.1 4.8
6.8 8.1 6.0
9.9 11.2 8.2
15.2 16.5 13.0
6-580.7
175,000 200,000 250,000 300,000
140,000 160,000 200,000 240,000
2357 2694 3367 4040
40-70 40-70 40-70 40-70
15 13 16 18
52 47 58 64
for motor size details, refer to pages 14 and 15.
factory
Control
unit
Installed
Code
voltage
selected
Transformer
115 1 30,63,85,87 115V to 24V
208 1 31,64,86,88 208V to 24V
208 3 31,64,86,88 208V to 24V
230 1 31,64,86,88 230V to 24V
230 3 31,64,86,88 230V to 24V
230 ➄ 3 64,88 230V to 24V
460 3 32,93 460V to 24V
230 ➄ 3 64,88 230V to 24V
575 3 33,94 575V to 24V
208/60/1
208/60/1
Total mtr. mtr. Total
0.87 1.0 1625 1.9
1.30 1.5 1075 2.8
1.74 --- --- ---
2.61 --- --- ---
2.61 --- --- ---
460/60/3
Total motor Total
Amps Amps Amps
2.5 0.7 1.9
2.5 0.6 1.9
3.4 1.1 2.4
4.0 1.4 2.6
4.8 1.8 3.0
6.1 2.4 3.6
7.3 3.0 4.3
9.5 4.1 5.4
14.3 6.5 7.8
350,000 400,000
280,000 320,000
4714 5387
40-70 40-70
19 19
67 68
Additional
field Installed
Transformers
none
none
none
none
none
460V to 230V ➅
460V to 230V
575V to 230V ➅
575V to 230V
230/60/1
230/60/1
mtr. mtr. Total
1.0 1625 1.9
1.5 1075 2.8
2.5 1075 3.7
3.5 1075 4.7
4.4 1125 5.5
575/60/3
motor Total
Amps Amps
0.5 1.8
0.8 2.1
0.9 2.2
1.1 2.3
1.5 2.6
1.9 3.1
2.3 3.5
3.4 4.6
5.3 6.5