Tensioning The Running Belt - Matrix T3xe Owner's Manual

TENSIONING THE RUNNING bElT

After placing the treadmill in the position it will be used, the belt must be checked for proper tension and centering. The belt might
need to be adjusted after the first two hours of use. Temperature, humidity, and use cause the belt to stretch at different rates. If the
belt starts to slip when a user is on it, be sure to follow the directions below.
A Locate the two hex head bolts on the rear of the treadmill. The bolts are located at each end of the frame at the back of the
treadmill. These bolts adjust the rear belt roller. Do not adjust until the treadmill is on. This will prevent over tightening of one side.
B The belt should have equal distance on either side between the frame. If the belt is touching one side, do not start the treadmill.
Turn the bolts counter clockwise approximately one full turn on each side. Manually center the belt by pushing the belt from side to
side. Tighten the bolts the same amount as when the user loosened them, approximately one full turn. Inspect the belt for damage.
C While the treadmill is running at 3 mph, observe the belt position. If it is moving to the right, tighten the right bolt by turning it
clockwise ¼ turn, and loosen the left bolt ¼ turn. If it is moving to the left, tighten the left bolt by turning it clockwise ¼ turn and
loosen the right ¼ turn. Repeat Step 3 until the belt remains centered for several minutes.
D Check the tension of the belt. The belt should be very snug. When a person walks or runs on the belt, it should not hesitate or slip.
If this occurs, tighten the belt by turning both bolts clockwise ¼ turn. Repeat if necessary.
NOTE: Use the orange strip in the lateral position of the side rails as criteria to confirm the belt is properly centered. It is necessary to
adjust the belt until the edge of the belt is parallel to the orange or white strip.
CAUTION
Do not run belt faster than 1 mph while centering. Keep fingers, hair and clothing away from belt at all times.
Treadmills equipped with side handrails and front handlebar for user support and emergency dismount, press emergency
button to stop the machine for emergency dismount.
12